|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
10-06-2018, 01:50 AM | #1 |
Not Yet Wild
Join Date: Oct 2018
Posts: 2
|
1993 DS gas starter generator stays running.
I fixed a stick valve issue on my DS and installed the engine back on the cart. I've checked all the wiring against the diagrams and its correct. Solenoid is good and replaced the 4 limit switches for good measure. But when I hook up the battery cables the starter/gen just starts running on it's own. It wont stop until cables are disconnected. I checked resistance across all terminals, the one that reads out of spec in the field coils. Could this be why it's doing that. I plan on just replacing with a new starter if so. Thanks.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-06-2018, 08:27 AM | #2 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,146
|
Re: 1993 DS gas starter generator stays running.
Check your solenoid and see if it is activated. If yes then try turning the key off and see if it stops. If yes then the pedal switch is bad or wired that way
|
10-06-2018, 09:23 AM | #3 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: 1993 DS gas starter generator stays running.
Sounds like the solenoid is hooked up wrong. The solenoid shouldn’t activate until you push the pedal. Remove the wires from the small posts on the solenoid and see if it still acts the same, if it does the solenoid is stuck closed.
Is anything pushing against the pedal? |
10-06-2018, 03:54 PM | #4 |
Not Yet Wild
Join Date: Oct 2018
Posts: 2
|
Re: 1993 DS gas starter generator stays running.
Can someone post a pic of the wiring hooked up at the solenoid and micro switches? I wired them exactly the way they were when I replaced them. Turning the key doesn't stop the starter and nothing is pushed against the pedal. I've checked everything against the schematic and I'm stumped. Thanks for your help!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
new starter/generator on g29 and now its not running well. any ideas? | Gas Yamaha | |||
1993 Cushman gas GT starter Generator wiring | Gas golf carts | |||
1993 ezgo marathon starter generator issues | Gas EZGO | |||
starter stays running | Gas Yamaha | |||
generator/starter running counter clockwise | Gas Club Car |