|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
02-02-2019, 04:43 PM | #1 |
Not Yet Wild
Join Date: Sep 2010
Location: Prince George Va.
Posts: 66
|
Plowmans Extreme Performance kit
For reference,has anyone done a step by step post on this kit installation?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-02-2019, 05:42 PM | #2 |
maintaining a low profile
Join Date: Oct 2009
Location: SW Virginia USA
Posts: 6,316
|
Re: Plowmans Extreme Performance kit
|
02-02-2019, 06:04 PM | #3 |
Not Yet Wild
Join Date: Sep 2010
Location: Prince George Va.
Posts: 66
|
Re: Plowmans Extreme Performance kit
Hey Dave..ahh I was panicking because I am far from carb.guru.There's 3 jets on this carb and there's 2 in the kit and I didn't see an instruction sheet (which isn't usually read till a else fails) with the kit.But I think I have it right..as it fired right up.
|
02-03-2019, 08:23 PM | #4 |
Not Yet Wild
Join Date: Sep 2010
Location: Prince George Va.
Posts: 66
|
Re: Plowmans Extreme Performance kit
Now getting this primary clutch off and out is a bear!
|
02-04-2019, 09:08 PM | #5 |
VC 460 CLONE GONE WILD
Join Date: Oct 2014
Location: Ray BY The Bay NJ
Posts: 10,644
|
Re: Plowmans Extreme Performance kit
It is easy with the proper puller and an impact gun.
|
02-05-2019, 04:15 PM | #6 |
Not Yet Wild
Join Date: Sep 2010
Location: Prince George Va.
Posts: 66
|
Re: Plowmans Extreme Performance kit
Raydhd,I have both,finally got the bolt loose and out with a ratchet strap and 2' breaker bar..clutch slid right off
|
02-05-2019, 05:14 PM | #7 |
VC 460 CLONE GONE WILD
Join Date: Oct 2014
Location: Ray BY The Bay NJ
Posts: 10,644
|
Re: Plowmans Extreme Performance kit
You lost me. Are you saying with an impact gun and the yamaha clutch puller tool the clutch wouldn't budge ?
|
02-05-2019, 08:25 PM | #8 |
Not Yet Wild
Join Date: Sep 2010
Location: Prince George Va.
Posts: 66
|
Re: Plowmans Extreme Performance kit
We had used the impact so much we were scared we were rounding the head.So we wrapped the clutch 3/4 times with the ratchet strap and hooked it to the cradle.Grabbed the breaker bar and AFTER lifting the drivers side wheel off the floor from pulling on the breaker bar, i stood on the rear tire while my buddy pulled on the breaker bar and the bolt finally broke lose.As we removed the bolt the clutch slid off the shaft.
|
02-05-2019, 09:06 PM | #9 |
VC 460 CLONE GONE WILD
Join Date: Oct 2014
Location: Ray BY The Bay NJ
Posts: 10,644
|
Re: Plowmans Extreme Performance kit
Sort of the opposite of my experience. I tried all sorts of rigs with a breaker bar. I called J&M and asked what I was doing wrong and they advice me that they had taken 1000's of primarys off with and impact gun and a welding glove. And presto the thing almost flew off. But Hey whatever works. Also struggled with the secondary until I broke down and bought the proper puller. Then it came off easy.
|
02-06-2019, 08:14 AM | #10 |
Not Yet Wild
Join Date: Sep 2010
Location: Prince George Va.
Posts: 66
|
Re: Plowmans Extreme Performance kit
Secondary was a breeze getting off,compared to primary, so what's the trick with the welding glove for future references?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Plowmans extreme performance kits for 2012.5-2014 g29 carts | Gas Yamaha | |||
2012.5 with plowmans extreme performance kit installed!!!! | Gas Yamaha | |||
performance lack after plowmans kit | Gas Yamaha | |||
Plowmans YDR Extreme Lifted Performance Kit | Gas Yamaha | |||
Plowmans G1 performance kit | Golf Carts and Parts |