2012 48v TXT slow forward normal reverse

Wolff · 07-02-2018, 10:56 AM

I have a 48v TXT first year worked as factory, then lately goes 6-7 mph forward and 8mph in reverse. These are the steps that have been taken so far:
-Had a computer connected to make sure it was not in Airport mode, it was not. Shop recommended motor swap, no change.
- (good thing I have 4 of this model cart) started part swapping one at a time.
-Motor
-Controller
-Speed Sensor and magnet
-Batteries
-Solenoid
-ITS
All parts were even swap and both carts test driven after each with no changes, in fact the other cart ran faster.
Any further suggestions greatly appreiciated.

JohnnieB · 07-02-2018, 01:33 PM

Use the computer to check the fault history.

Wolff · 07-02-2018, 04:35 PM

The campground actually does not own a computer, we took it 75miles and had a company that has one hook up to it.
I did find the problem though, I found that the Speed Sensor harness had frayed Black and Red wires just after it went onto the main harness behind the solenoid. Cut the bad sections out, crimped and runs at 14mph again. Now all I have to do is replace the charger and it cam be rented again.

kgsc · 07-02-2018, 07:47 PM

A DPI with the SB50 plug would be a good choice for you sounds like. With the correct jumper cable it be used pretty much with most 48 volt carts.

07-02-2018, 10:56 AM	#1
Wolff Not Yet Wild Join Date: Jul 2018 Location: Virginia Beach Posts: 2	2012 48v TXT slow forward normal reverse I have a 48v TXT first year worked as factory, then lately goes 6-7 mph forward and 8mph in reverse. These are the steps that have been taken so far: -Had a computer connected to make sure it was not in Airport mode, it was not. Shop recommended motor swap, no change. - (good thing I have 4 of this model cart) started part swapping one at a time. -Motor -Controller -Speed Sensor and magnet -Batteries -Solenoid -ITS All parts were even swap and both carts test driven after each with no changes, in fact the other cart ran faster. Any further suggestions greatly appreiciated.

07-02-2018, 01:33 PM	#2
JohnnieB Techno-Nerd Join Date: Jun 2011 Location: West Virginia Posts: 19,654	Re: 2012 48v TXT slow forward normal reverse Use the computer to check the fault history.

07-02-2018, 04:35 PM	#3
Wolff Not Yet Wild Join Date: Jul 2018 Location: Virginia Beach Posts: 2	Re: 2012 48v TXT slow forward normal reverse The campground actually does not own a computer, we took it 75miles and had a company that has one hook up to it. I did find the problem though, I found that the Speed Sensor harness had frayed Black and Red wires just after it went onto the main harness behind the solenoid. Cut the bad sections out, crimped and runs at 14mph again. Now all I have to do is replace the charger and it cam be rented again.

07-02-2018, 07:47 PM	#4
kgsc Gone Wild Join Date: Dec 2009 Location: Aiken, SC Posts: 13,120	Re: 2012 48v TXT slow forward normal reverse A DPI with the SB50 plug would be a good choice for you sounds like. With the correct jumper cable it be used pretty much with most 48 volt carts.

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

Similar Threads
Thread	Forum
2012 RXV Will not Forward or Reverse but clicks	Electric EZGO
2012 club car precedent forward reverse switch	Electric Club Car
Forward normal.... no reverse whatsoever	Electric Club Car
91 Club car seems normal speed forward, but almost no power in reverse	Electric Club Car
Slow forward - really slow reverse - 91 DS	Electric Club Car