|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
09-24-2016, 02:44 PM | #1 |
Not Yet Wild
Join Date: Sep 2016
Posts: 5
|
Golf cart stops while moving
We have a 2010 Club Car Precedent Electric Golf Cart. We have just replaced all 6 batteries and the Solenoid. The Golf Cart stops running while moving slowly. If you run it down the road wide open for a few minutes it stops the problem. When it stops you have to let off the pedal and press it again and it will start back. Please advise.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-24-2016, 06:58 PM | #2 | |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: Golf cart stops while moving
Quote:
This is possibly an MCOR problem. This is the electronic throttle box that sends a signal to the controller. Turn the cart off, put it in neutral, and pump the go pedal 20-30 times, all the way down and back up. Then drive the cart and see if things improve. This procedure will clean the wiper board inside the MCOR. |
|
09-25-2016, 12:36 PM | #3 |
Not Yet Wild
Join Date: Sep 2016
Posts: 5
|
Re: Golf cart stops while moving
Thank you we will try that.
|
09-25-2016, 01:17 PM | #4 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: Golf cart stops while moving
No need to try that, it has the new style MCOR on it.
I'm going to assume this problem didn't exsist prior to the batteries-solenoid being replaced? Why was the solenoid replaced and what did you replace it with? Are all connections tight on solenoid and Controller? This tends to be where this type of problem come from. |
10-02-2016, 06:19 PM | #5 |
Not Yet Wild
Join Date: Sep 2016
Posts: 5
|
Re: Golf cart stops while moving
We replaced the solenoid because what we had read suggested this could be the problem. This problem has been going on for quite some time. We tried the earlier suggestion and it did not help.
|
10-02-2016, 08:17 PM | #6 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: Golf cart stops while moving
Is the solenoid dropping out when the cart stops? Do you hear it click?
|
10-03-2016, 08:16 PM | #7 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Re: Golf cart stops while moving
Not sure if this will help your issue , my cart was doing something similar . But also would get beep from anti-roll warning . My cart is a 2010 also turned out the diode went bad . Sergio from this site identified this . I pick up a diode at radio shack and put in in series with old one and it solved my issue . Waiting to bring it home from campground and order a new Oem from revolution carts . Try searching for (solenoid dropping out ) on this site . If u can't find give Sergio a shout out . Hope this helps and best of luck !
|
10-10-2016, 06:56 PM | #8 |
Not Yet Wild
Join Date: Sep 2016
Posts: 5
|
Re: Golf cart stops while moving
No the solenoid is not dropping out. It is brand new and was just replaced in an effort t fix this problem.
|
10-10-2016, 07:13 PM | #9 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: Golf cart stops while moving
Have you tried jumping the two pin connection on the MCOR?
|
10-10-2016, 07:56 PM | #10 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Re: Golf cart stops while moving
If cart is stopping odds are solenoid is either not closed or coil is not energized . If coil is staying closed and energized motor may be issue . Have you connected a multi meter to solenoid coil and verify coil is not opening when cart is stopping . Is cart actually stopping or is motor braking occurring ?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Ezgo 2002 Stops Moving | Electric EZGO | |||
2003 Club Car stops moving | Electric Club Car | |||
1996 club car stops moving and hesitates | Electric Club Car | |||
golf cart stops out of no where. | Electric Club Car | |||
2007 G22 Starts moving then stops | Electric Yamaha |