1995 Club Car A9502 F&R Switch

[Sergio]

Either location is fine for this purpose.

[rstief@yahoo.com]

Originally Posted by Mooncarter

I have an early 95 just like yours. Not having the diagram above was a headache. See my thread: "1995 Club Car Won't Run." Might be some things in there to help you.

I haven't check all that hard but do you have a electric digram for all the wires/fuses behind the dashboard?

[rstief@yahoo.com]

Unable to see fuse on small yellow. Fuse on charger looks OK.
I did plug in charger, it jumped to about 16 amps , then looked like breaker turned it off right away but then popped right back around 15amps and after 5 mins. holding about 13 amps. Any idea how long it might take to see if it actually stops charging. I think batteries were around 47.8.

[rstief@yahoo.com]

Can someone tell me what this is? It is located on the frame nears the solenoid. Has yellow wire running from solenoid into it and two red wires coming out going back to?Controller?
The black you see is a plastic tie.

[Fairtax4me]

Originally Posted by rstief@yahoo.com

According to the wiring diagram , they said that was for this early 1995 CC, it is showing a green wire from key switch to the large red on solenoid.
Anybody have some info on this?

This is what my solenoid looks like.

The big red cable needs to be first on the post here and the other smaller wires put on after it. Someone has removed it and put the smaller wires on the bottom and this causes a high resistance path for the battery current to get through the connection here. It can cause the solenoid post and cable end to overheat and burn.
I would remove all of those and clean them very well with a wire brush to make sure there is a good clean connection.

[Mooncarter]

Originally Posted by rstief@yahoo.com

Unable to see fuse on small yellow. Fuse on charger looks OK.
I did plug in charger, it jumped to about 16 amps , then looked like breaker turned it off right away but then popped right back around 15amps and after 5 mins. holding about 13 amps. Any idea how long it might take to see if it actually stops charging. I think batteries were around 47.8.

Might run up to 16 hours.

[rstief@yahoo.com]

Well it looks like this is up and running. I have a happy neighbor. Thanks everybody with all the help, couldn't have done it without you.

[Mooncarter]

Good news!

[hot-shot]

I have a 1995 Club car ds. I bought It from a neighbor. He said that it would only run in reverse. He said that he had bought a new forward reverse switch but had not installed it. When I removed the old one it had a burned post on the passenger side of the switch. Once I installed the new switch I only have forward. I rechecked the wiring it seems to be correct. Any help would be appreciated. Thanks