lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-11-2015, 10:27 PM   #1
andrew520
Not Yet Wild
 
Join Date: Feb 2013
Posts: 10
Default G1 w/ G16 Engine - Hot Starting Issues

So I have a Yamaha G1 that has a 1998 4-stroke G16 engine in it. Starts up fine when cold but after running for awhile if you stop it just doesn't want to turn the starter motor. It has the dual solenoid setup still on it which is for forward and reverse (it has the G1 rear end so I don't have reverse) so I thought maybe the solenoid was bad. I switched the two around and have the same problem. After sitting for a few minutes randomly pushing the accelerator pedal it will then take off and its good again until I stop or let it cool down. When it fails it doesn't initiate the starter so the problem is isolated away from the Fuel/Air/Spark categories.

When it won't start and I push the accelerator I can hear the solenoid click on the fender.

What's been done:

New starter generator, didn't run at all before replacing this.. not even a month old,
new battery,
new ignition switch,
new battery cables to starter motor
swapped the solenoids around
andrew520 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
Starting Issues Gas Club Car
G16 starting issues Gas Yamaha
Engine Swap Starting Issues... (Video) Gas Yamaha
97 TXT Starting issues Gas EZGO
G2 have starting issues Gas Yamaha


All times are GMT -5. The time now is 04:26 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.