|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-28-2015, 10:16 PM | #1 |
Getting Wild
Join Date: Sep 2010
Posts: 77
|
cart lunges full throttle in forward and reverse....
I have a 06 ds iq with alltrax dcx 500 controller and cart has recently just lurches to full throttle with pedal depressed..in forward and reverse....will peel out on gravel....seems to just want to run full tilt? any suggestions?[/
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-29-2015, 09:20 AM | #2 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: cart lunges full throttle in forward and reverse....
Check your throttle settings. Once I accidentally selected a 0 to 5k setting instead of 5k to 0 CC setting
|
11-29-2015, 11:23 AM | #3 |
Getting Wild
Join Date: Sep 2010
Posts: 77
|
Re: cart lunges full throttle in forward and reverse....
thanks, but I had installed controller 2 years ago and these symptoms just appeared out of no where.....
|
11-29-2015, 11:33 AM | #4 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: cart lunges full throttle in forward and reverse....
I have not heard of the Alltrax controllers loosing their configuration, but if it did, that could certainly cause an issue.
If You plug the software it will also allow you to monitor the throttle input percentage so You can see what is happening. The only other thing to try is to remove the 3-pin connector from the MCOR to see if the MCOR is somehow causing the problem. |
11-29-2015, 12:19 PM | #5 |
Getting Wild
Join Date: Sep 2010
Posts: 77
|
Re: cart lunges full throttle in forward and reverse....
all points appear to faulty MCRO at this point???...according to installation for alltrax controllers speed sensor to stock motor remains disconnected..
|
11-29-2015, 12:46 PM | #6 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: cart lunges full throttle in forward and reverse....
It could also be an interface board, controller issue or short in the MCOR harness.
If You disconnect the 3-pin connector and the cart still goes full speed when You press the pedal and close the micro switch on the 2-pin connector, then the issue is not the MCOR. |
|
|
Similar Threads | ||||
Thread | Forum | |||
cart goes full speed in reverse not forward | Electric Club Car | |||
83 ezgo full power in reverse, not so much in forward | Gas EZGO | |||
full forward to full reverse... a blown fuse? | Electric golf carts | |||
95 Club Car Won't Run Full Throttle Forward | Electric Club Car | |||
Full power in Reverse but very little going forward?? | Gas EZGO |