|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-04-2023, 01:29 PM | #1 |
Not Yet Wild
Join Date: Jun 2023
Posts: 5
|
Club Car Precedent runs but won't charge
Have an 04-07 model, unsure which exact year as I bought used and serial is missing. 48v 4x12.
Changed the batteries last week to Trojans and the cart runs great. Only issue is it no longer takes a charge after installing the new batteries myself. Worked fine before so I don't think it's an issue with the charger. Is it possible that I hooked up the batteries in a way that allows the cart to run, but not take a charge? Used new cables and cleaned everything when the battery swap was done, and it runs, so I don't think it's a dirty/bad wire issue. Any advice or guidance would be greatly appreciated. Sent from my iPhone using Tapatalk |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-04-2023, 02:31 PM | #2 |
Gone Wild
Join Date: Feb 2014
Location: Stuart, FL
Posts: 386
|
Re: Club Car Precedent runs but won't charge
Did you hook the charge receptacle back up correctly? Need to see pics of your wiring.
|
06-05-2023, 06:46 AM | #3 |
Gone Wild
Join Date: Sep 2022
Location: Minnesota
Posts: 1,311
|
Re: Club Car Precedent runs but won't charge
Did you make sure you main Neg runs through the OBS if it was not previously bypassed?
|
06-05-2023, 01:30 PM | #4 |
Not Yet Wild
Join Date: Jun 2023
Posts: 5
|
Re: Club Car Precedent runs but won't charge
Pic before changing batteries
|
06-05-2023, 01:31 PM | #5 |
Not Yet Wild
Join Date: Jun 2023
Posts: 5
|
Re: Club Car Precedent runs but won't charge
After changing batteries
|
06-05-2023, 01:33 PM | #6 |
Not Yet Wild
Join Date: Jun 2023
Posts: 5
|
Re: Club Car Precedent runs but won't charge
Forgive my ignorance but I have no idea what this means. I just took notes/pics of the setup before removing the old ones, then installed the new ones and figured everything was correct when the cart turned on and ran properly.
If you could expand on this for a beginner I'll check when I get home this afternoon and report back. |
06-05-2023, 02:24 PM | #7 |
Gone Wild
Join Date: Sep 2022
Location: Minnesota
Posts: 1,311
|
Re: Club Car Precedent runs but won't charge
OBC=On Board Charge Controller. The last negative( The one that comes off the pack and runs to the controller) should run through the OBC.
I see I called it by the wrong name on my original post. |
06-06-2023, 09:11 PM | #8 |
Not Yet Wild
Join Date: Jun 2023
Posts: 5
|
Re: Club Car Precedent runs but won't charge
bump
Sent from my iPhone using Tapatalk |
06-07-2023, 03:59 AM | #9 |
Gone Wild
Join Date: Feb 2014
Location: Stuart, FL
Posts: 386
|
Re: Club Car Precedent runs but won't charge
Check the charge receptacle make sure you have the red going to the main positive of the pack and the black running through the OBC (if it has one) and then another black goes to the main negative. If it has a little grey wire on the receptacle check it , that wire corrodes a lot and is the “sense” wire to start the charger. The pack voltage also has to be above 36 or something volts to trigger the charger. Did you run the cart dead after new batteries?
I probably should ask what charger are you using? |
06-07-2023, 10:57 PM | #10 |
Getting Wild
Join Date: Jul 2008
Posts: 114
|
Re: Club Car Precedent runs but won't charge
I can’t see your pic very well but if your cart is like a 2005. It looks like the pack positive (front batt under the drivers side) is missing a cable. Look for a cable coming from the front end of that middle console. It should be black. I have seen the cable missed as it can be laying down between the batts and that middle cover. The cable is also long enough that I have seen it mistakenly connected to the rear battery.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2013 Club Car Precedent - runs when key is off + headlights on | Electric Club Car | |||
2004 Club Car Precedent Runs 10 min dies then runs | Electric Club Car | |||
2008 Club Car Precedent Runs with disconnected solenoid | Electric Club Car | |||
2011 Club Car Precedent runs slow | Electric Club Car | |||
club car Gas precedent runs Jerky | Gas Club Car |