|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-03-2020, 01:12 PM | #1 |
Not Yet Wild
Join Date: May 2020
Posts: 15
|
cart not moving or charging
The kids were driving my cart, said they stopped and the cart would not move again. I plugged the cart in to charge. The chargers shows 15 Amps going into the cart for a short time (approx. 1 minute) then the fuse on the charger pops. Push it in and same thing. Also no clicking on the solenoid. Any idea if i should be looking to the micro switches on the FNR bell or the solenoid? Any one with experience think the problems are related? I am guessing an open in the system which is drawing the charger to its max until it pops? Batteries show 49V with a meter.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-04-2020, 01:41 AM | #2 |
Not Yet Wild
Join Date: May 2020
Posts: 15
|
Re: cart not moving or charging
update... i replaced the entire FnR and microswitches same symptoms. hmmm test solenoid next?
|
08-04-2020, 02:12 AM | #3 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,215
|
Re: cart not moving or charging
Year, model, and drive system of the cart?
|
08-04-2020, 02:14 AM | #4 |
Not Yet Wild
Join Date: May 2020
Posts: 15
|
Re: cart not moving or charging
Club Car DS 1997 48V.
D&D speed motor 600A navitas controller 400A solenoid Controller shows voltage (5V i think) when the peddle is pressed down. I disconnected the negative battery connection for 10 minutes to try and reset the OBC. |
08-04-2020, 05:55 AM | #5 |
Gone Wild
Join Date: Oct 2008
Location: East Texas
Posts: 586
|
Re: cart not moving or charging
sounds like a weak circuit breaker on the charger,
|
08-05-2020, 01:47 AM | #6 |
Not Yet Wild
Join Date: May 2020
Posts: 15
|
Re: cart not moving or charging
I tried another charger which did not pop the circuit. I think you were correct about the charger. I also found a wire behind the ignition had fallen loose and caused the "no solenoid click" condition. Back on the road! Thank you!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2004 Club Car, Charging but no moving? | Electric Club Car | |||
Help! Cart not moving | Electric Club Car | |||
New to me cart not moving | Electric EZGO | |||
cart not moving | Electric Club Car | |||
Re: CART NOT MOVING AT ALL. | Electric Club Car |