|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-02-2018, 10:06 AM | #1 |
Not Yet Wild
Join Date: Nov 2011
Posts: 73
|
1994 TXT series strange power!
I’m working on a 1994 Txt medalist series cart and following the diagnostics thread from scottyb as it doesn’t drive, I got it non running.. Battery pack was reading 37.7 during testing (it’s on the charger now).
On the battery side of solenoid I have 37.7. On controller side of solenoid, wth key on in forward and no throttle pedal pressed I have 18.1!! No matter what I get no solenoid click, even with the jumper with described in the diagnostic thread. I have tried 2 different solenoids and 2 different controllers. I had them, wasn’t throwing parts at it but now I’m stumped. How on earth is it getting power to the controller side of the solenoid without the solenoid being activated, and why 18.1!?!?!? Thanks for any help. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-02-2018, 11:34 AM | #2 | |
Gone Wild
Join Date: Sep 2016
Location: Northern California
Posts: 1,300
|
Re: 1994 TXT series strange power!
Quote:
Either way, if you’re not getting the solenoid to click, you need to focus on the activation circuit. Pack voltage at the small solenoid terminals with the pedal depressed and rear wheels off the ground? No? Start at the charge port and go from there. |
|
12-02-2018, 12:41 PM | #3 |
Not Yet Wild
Join Date: Nov 2011
Posts: 73
|
Re: 1994 TXT series strange power!
Just tried it without capacitor, same reading. Also, with the solenoid not activating with the jumper wire I’m confused.
|
12-02-2018, 12:41 PM | #4 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 1994 TXT series strange power!
Quote:
TXT = Plastic body Medalist = Metal body. 2. No solenoid click means there is a problem in the solenoid activation circuit. The solenoid's battery side and controller side large terminals are in the high current circuit and ought to be troubleshot after the no solenoid click problem is solved, if need be. Attached is a schematic with solenoid activation circuit highlighted. 3. The reason there is a voltage on the solenoid's controller side large terminal is due to the pre-charge resistor between the two large terminals. The resistor is there to keep the filter capacitors inside the controller charge to battery pack voltage less the voltage drop caused by amp flow through the resistor (250Ω for a 36V system). Amp flow is due to the filter capacitors having bleed resistors across them so they are discharged in a few minutes for safety reasons when controller is removed or disconnected from cart. Normally, the bleed rate is in the 10mA to 20Ma range, so the voltage found on the controller side large terminal is typically 3V to 5V less than the battery pack voltage at the time. Looks like the resistor is dropping 19.6V (37.7 - 18.1), so there is upwards of 80mA flowing through the 250Ω resistor, which might mean a bad capacitor or a bad MOSFET in the controller, but there may be another explanation for it. Just have to check it out after you fix the solenoid not clicking problem. |
|
12-02-2018, 12:44 PM | #5 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 1994 TXT series strange power!
Quote:
It'll take a few minutes for the capacitors to bleed off the charge. There is enough energy stored on those capacitors to move the cart a foot or two if the controller powered up and had a throttle signal. |
|
12-02-2018, 12:57 PM | #6 |
Gone Wild
Join Date: Sep 2016
Location: Northern California
Posts: 1,300
|
Re: 1994 TXT series strange power!
Jelly, get on this thing while you have johnnieb’s attention. Stick with him step by step and he’ll get you there.
|
12-02-2018, 01:05 PM | #7 |
Not Yet Wild
Join Date: Nov 2011
Posts: 73
|
Re: 1994 TXT series strange power!
Sorry I misspoke. I meant the resistor.
Also, cart doesn’t have a body currently. Started as a medalist, getting a plastic TxT body, not sure which way it identifies today. I’ll trace the entire activation circuit and post what I find. Previous owner said he replaced the pedal box MS. Not sure what lead him to do that. |
12-02-2018, 01:26 PM | #8 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 1994 TXT series strange power!
Quote:
What to call it? That is a good question. Unless you need body parts or accessories, it doen't matter what it is called, but somebody might notice that the TXT body wasn't introduced until 1996. |
|
12-03-2018, 10:36 AM | #9 |
Not Yet Wild
Join Date: Nov 2011
Posts: 73
|
Re: 1994 TXT series strange power!
Working more on this and I might be narrowing in on the problem. Working through the diagnostic thread I get to the part of checking the ITS. With jumper wire from pack posts small post on solenoid to activate solenoid, Neg probe on pack neg post positive probe on white wire going into controller. I don’t get the required volts. So I switch out ITS with another and same problem but both work fine in other cart. I have ohm’d all of the wires from pedal box to their desitnation and no problems there.
I’m stumped. Help! |
12-03-2018, 11:39 AM | #10 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: 1994 TXT series strange power!
Quote:
2. What is the voltage on the black wire? If it is wrong, the voltages on the white wire will be wrong also. 3. I'm not sure which diagnostic thread you are using, some of the leave a lot to be desired. Please post link to it. 4. Have you tried a different controller? The 18.1V on the controller side terminal pointed to a bad controller. 5. Use a voltmeter for troubleshooting. Ohmmeters don't always tell the truth. |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Is my motor shot? Strange smell, reduced power | Electric EZGO | |||
Strange loss of power | Electric EZGO | |||
Strange problem with new marine 12v power socket | Electric Club Car | |||
strange way to power a golf cart! | Electric EZGO | |||
Strange vibration 1994 EZGO | Electric EZGO |