|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
07-23-2020, 02:40 PM | #11 |
Not Yet Wild
Join Date: May 2012
Location: stansbury park
Posts: 18
|
Re: RXV won’t go in forward or reverse..sometimes?
would the motor brake be the same in my 2015 as one in a 2010? my friend has a 2010 that i can swap the motor brake from and try out
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-23-2020, 02:54 PM | #12 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,238
|
Re: RXV won’t go in forward or reverse..sometimes?
Yes but if you ever buy another brake make sure it is a EZGO OEM brake.
Replacing the Park Brake on an E-Z-GO RXV Remove the two T27 torx screws on the rear cover Choke the wheels Disconnect the negative cable on the battery pack Turn the ignition key to reverse, wait till the reverse indicator becomes silent then turn key off Disconnect wire harness from motor brake Remove the three 10mm hex screws and lock washers from brake If bolts are rusty replace them Remove brake if there is residue on motor be sure to clean it use a wire brush Position the brake with the connector at the top, install the three hex screws loosely. Connect wire harness to the motor brake, re-connect battery negative cable Turn ignition to neutral, turn Run/Tow switch to Tow position, this provides power to the brake to align the disc material Set torque wrench between 53 to 65 in. lbs (6-8 Nm) and tighten screws be sure not to over tighten Turn key back to the off position Move Run/Tow switch back to Run position Put rear back cover on |
07-23-2020, 07:37 PM | #13 |
Not Yet Wild
Join Date: May 2012
Location: stansbury park
Posts: 18
|
Re: RXV won’t go in forward or reverse..sometimes?
just took it out for a drive and noticed a little more of the issue. If im driving and let off the pedal to decelerate then push the pedal to the floor the cart wont move, like its lost all power. If I let off the pedal to decelerate i need to slowly push the pedal to the floor in order to keep going or it acts like all power is shut off. Same thing in reverse as well. I slowly pushed the pedal down to reverse and all was good, if i push the pedal to far to quick then it wont move.
The original problem is still happening, this is just something else i noticed once it did actually want to move. It doesnt feel like the motor brake is locking up but its kinda making me think thats more possibility of the problem now. Any input? |
07-24-2020, 08:17 AM | #14 | |
Gone Wild
Join Date: Jun 2010
Location: Georgia
Posts: 470
|
Re: RXV won’t go in forward or reverse..sometimes?
Quote:
|
|
07-27-2020, 06:27 AM | #15 | |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: RXV won’t go in forward or reverse..sometimes?
Quote:
|
|
07-28-2020, 03:50 PM | #16 |
Not Yet Wild
Join Date: May 2012
Location: stansbury park
Posts: 18
|
Re: RXV won’t go in forward or reverse..sometimes?
Bob, so what do you think would cause this? Bad batteries? They are U.S. Battery from 2018. The PO had the auto drip system installed and i checked the batteries a few weeks ago(the night i purchased it). The acid level was all over the place but none were low, almost all were overfilled. I pulled the batteries to clean everything and there was crusted and some gooey acid everywhere
|
07-28-2020, 05:25 PM | #17 | |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: RXV won’t go in forward or reverse..sometimes?
Quote:
|
|
07-29-2020, 12:00 AM | #18 | |
Not Yet Wild
Join Date: May 2012
Location: stansbury park
Posts: 18
|
Re: RXV won’t go in forward or reverse..sometimes?
Quote:
I have a 48V TXT with 1 year old Trojans. I will swap batteries and see if it does anything. Thank you for the input |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
94 Club Car DS drives Forward in Reverse and Reverse in Forward | Gas Club Car | |||
Forward/Reverse, drives forward then jumps in reverse | Electric EZGO | |||
2006 ezgo forward is reverse and reverse is forward please help | Electric EZGO | |||
Reverse alarm sounds in Forward, wont go forward or reverse | Electric Club Car | |||
Forward Reverse switch melted on forward...have question about replacement part | Electric Club Car |