|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
03-27-2013, 08:11 PM | #1 |
Not Yet Wild
Join Date: Jun 2009
Posts: 45
|
PDS cart stuck in slow mode
I just rebuilt a flooded cart. Here are the details. Rebuilt motor, new speed sensor, rebuilt controller, all new wiring harness, new run/tow switch, new solenoid, new cables, new batteries, . The cart takes off normal then it seems to dump and will then only travel very slow. If you cycle the run tow switch it will take off normal again and then do the same thing. Any ideas?
Thanks, Scott |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-27-2013, 08:19 PM | #2 |
Gone Wild
Join Date: Mar 2011
Location: The hills of WV...
Posts: 330
|
Re: PDS cart stuck in slow mode
What about the forward and reverse switch? is it new?
|
03-27-2013, 08:31 PM | #3 |
Not Yet Wild
Join Date: Jun 2009
Posts: 45
|
Re: PDS cart stuck in slow mode
No, it is the same switch. The water never made it that high. It goes forward and revers. It also dumps off in reverse.
|
03-27-2013, 08:42 PM | #4 |
Gone Wild
Join Date: Mar 2011
Location: The hills of WV...
Posts: 330
|
Re: PDS cart stuck in slow mode
did you clean ALL contacts on the f/r switch? what is the voltage at the start v/s when it dumps?
|
03-27-2013, 10:44 PM | #5 |
Not Yet Wild
Join Date: Jun 2009
Posts: 45
|
Re: PDS cart stuck in slow mode
All the terminals are clean. It is over 36 volts.
|
03-28-2013, 04:22 AM | #6 |
Gone Mad
Join Date: Oct 2009
Location: Buford, GA
Posts: 8,988
|
Re: PDS cart stuck in slow mode
What about the throttle sensor?
Links: Owner's, Parts, and Service Manuals: http://www.buggiesgonewild.com/elect...g-manuals.html Dana Axle: http://www.buggiesgonewild.com/attac...5-28148g01.pdf |
03-28-2013, 06:43 AM | #7 |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: PDS cart stuck in slow mode
Put the controller in diagnostic mode and maybe it'll give you a beep-code when it goes into the reduced performance condition.
Text on bottom of attached label tells you how to enter the diagnostic mode and what the beep-codes mean. ------------ Also, what is the battery pack voltage when it misbehaves? (36V is only about 50% SoC) |
03-28-2013, 08:45 AM | #8 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,408
|
Re: PDS cart stuck in slow mode
I'm suspecting the motor speed magnet might have something to do with this strange behavior ..... ?
|
03-28-2013, 08:46 AM | #9 |
Not Yet Wild
Join Date: Jun 2009
Posts: 45
|
Re: PDS cart stuck in slow mode
Scotty, are you talking about the speed sensor or the magnet in the motor that drives the sensor? Can the magnet be replaced?
Thanks, Scott |
11-14-2018, 03:39 PM | #10 |
Not Yet Wild
Join Date: Nov 2018
Posts: 1
|
Re: PDS cart stuck in slow mode
Sorry to revive this old topic but I have the exact same problem as described in this thread.
Flooded cart, replaced batteries and motor, measured all contacts in controller etc all seems fine, still dumps to slowmode after takeoff. How did you solve this? |
|
|
Similar Threads | ||||
Thread | Forum | |||
cart runs in tow mode | Electric Club Car | |||
88 ezgo gas starter/generator stuck in starter mode | Gas EZGO | |||
Installed new batteries with Cart in Run Mode...not Tow/Maintenance | Electric EZGO | |||
Cart won't go after getting stuck | Electric EZGO | |||
Got my Cart stuck today | Lifted Golf Carts |