01-26-2015, 09:30 PM | #1 |
Not Yet Wild
Join Date: Oct 2014
Location: Florida
Posts: 5
|
2005 CCDS GAS No Start
Hello I am new to the forum and golf cart repair, but have a long history of automotive tinkering. I have a 2005 Gas DS that was running a week ago. I went out to move it and it will not start. Engine turns well will not start.
Motor FE290D Details: Motor spins Good Compression 150 psi Spark on plug when out of motor grounded to block. Was hearing some back firing into air box (suspected valve issue) Pump is working Tried: Checked valve clearance Pulled carb and cleaned Pulled flywheel to check for broken key Checked and adjusted coil gap Pulled head and checked for valve/seat damage Today reassembled had rear end up on stands for testing and cart fired up and ran well. (I thought fixed) Let it down pushed out of garage and you guessed it NO START Could the angle of the cart have something to do with why the cart started? Fuel level in bowl ? I am completely stumped. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-27-2015, 05:48 AM | #2 |
Photoshop Guy
Join Date: Aug 2012
Location: Canal Fulton, OH
Posts: 3,846
|
Re: 2005 CCDS GAS No Start
Is the spark plug wet after you try to start it unsuccessfully?
|
01-27-2015, 07:24 AM | #3 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,186
|
Re: 2005 CCDS GAS No Start
I would disconnect the ground wire on the rev limiter and try it then. May have gone bad..
|
01-27-2015, 08:10 AM | #4 |
Not Yet Wild
Join Date: Oct 2014
Location: Florida
Posts: 5
|
Re: 2005 CCDS GAS No Start
I will check and get back to you
|
01-27-2015, 08:30 AM | #5 |
Not Yet Wild
Join Date: Oct 2014
Location: Florida
Posts: 5
|
Re: 2005 CCDS GAS No Start
|
01-27-2015, 09:50 AM | #6 |
Gone Wild
Join Date: Apr 2014
Location: dallas tx
Posts: 185
|
Re: 2005 CCDS GAS No Start
Theres a rev limiter box. Its down at the bottom of the engine on the front side by the oil tube. Just disconnect the brown ground wire.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2005 Club car gas doesn't start when I turn the key | Gas Club Car | |||
2005 gas Yamaha hesitates to start | Gas Yamaha | |||
2005 ezgo 2 stroke will start but not move | Gas EZGO | |||
2005 ST350 Engine will not start | Gas EZGO | |||
2005 EZGO won't start | Gas EZGO |