|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
12-30-2008, 04:27 PM | #11 |
Born Wild
Join Date: Mar 2007
Location: Clover SC.
Posts: 5,552
|
Re: Headlight problems for EZGO gas Sport ST 01'
I'm guessing nothing else there, I can't be sure what someone has done to a cart I know nothing about or have never seen. Factory setup is pretty straight forward unless you have blinkers, goes from battery to the fuse to the key switch to the lights. The wiring diagrams are in the manuals in the tech section. my guess would be bad connection or wire or switch in that order.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-30-2008, 05:36 PM | #12 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: Headlight problems for EZGO gas Sport ST 01'
Can I suggest you pull the switch out of the dash turn to lights on and with a test light see if your light terminals are hot on the switch.....On mine it was dead at the switch. I had power for ignition but, nothing at the lights = a bad switch .... so I just added a light switch ....... or buy a new OEM ignition. Bet that's it?
|
01-03-2009, 01:25 PM | #13 |
Not Yet Wild
Join Date: Dec 2008
Posts: 9
|
Re: Headlight problems for EZGO gas Sport ST 01'
Scott,
I'll check the hot off the switch, but it's a NEW switch; just put it in as part of the diagnosing process. It's got me stumped, I've gone through the connections, everything appears to be in order except for one set of the lights not getting power; it's been a couple of days since I've looked at the circuit, but it's either the headlight or the yellow amber light wiring sets that are without power. I'm guessing both need to have power for the circuit to be complete, but I'm not sure where the connection problem/short is located. Since one of the wire circuits are sending power, I'm also guessing the (new) switch is hot and operating correctly. I'll post my findings in a few days, thanks for the feedback, folks. ~ rob |
01-03-2009, 04:16 PM | #14 |
Gone Crazy
Join Date: Jan 2007
Location: Chesterfield, Va
Posts: 6,021
|
Re: Headlight problems for EZGO gas Sport ST 01'
Both headlight bulbs were bad on one I was working on.
What are you finding with the meter? Following the curcuit with a meter will smoke out the problem. One thing I like to do with curcuits is start in the middle. that way you have half checked, from middle to end or middle to beginning and a 50% head start. but that's just me. |
04-16-2021, 07:04 AM | #15 |
Gone Wild
Join Date: Jul 2020
Location: NC
Posts: 773
|
Re: Headlight problems for EZGO gas Sport ST 01'
Are the lights shot? You can run 12v pigtail straight to the two wire posts on the back of each light, should come on if the bulbs are good. You need 12 volts for these lights...I've tried with less, and they won't come on. Assuming both bulbs are functional, you have a blue wire with white stripe that runs from the fuse box up to the back of the ignition switch, another similar wire that leaves that switch and goes out to the light circuit connectors and two each light. You then have ground wires that come together and tie to a common ground. Assuming all the wires are connected, and both bulbs work, it would have to be the common ground wire for the light circuit, or any functional bulbs would come one. If the one common ground isn't good, all lights won't work.
|
04-16-2021, 07:26 AM | #16 |
British born Nincompoop
Join Date: Feb 2007
Location: United Kingdom
Posts: 2,463
|
Re: Headlight problems for EZGO gas Sport ST 01'
Look at the post dates JP. It's an old thread been spammed!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
EZGO RXV Headlight Kit | Design Center | |||
EZGO Gas ST Sport ll | Gas EZGO | |||
Big Block EZGO ST Sport for sale | Golf Carts and Parts | |||
EZGO headlight bar | Golf Carts and Parts | |||
2008 EZGO ST Sport | Gas EZGO |