lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car
Gas Club Car Gas DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-24-2012, 03:10 PM   #1
Kelley97
Not Yet Wild
 
Join Date: Jul 2012
Posts: 4
Default '01 Club Car won't run!

I have an '01 Club Car that won't run. I have soaked and cleaned the carb and fuel pump(idea I got from you guys advise on here). Tried to start it with the airbox lid open and no luck. Replaced the spark plug. If you get it to crank, it will run for 30 secs or so wide open and then cut off. I took the rev limiter off a couple of years ago and have been running it with no problem until now. Help please!
Kelley97 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 07-24-2012, 03:53 PM   #2
Kelley97
Not Yet Wild
 
Join Date: Jul 2012
Posts: 4
Default Re: '01 Club Car won't run!

Just went back up to my shop and looked at my golf cart again. Pinched the hose come from beside the valve cover and it started. Ran like a champ. Got across the yard and it shutt off ahain. It has to be something electrical I guess. I read something about the ignitor. My must be working intermittantly.
Kelley97 is offline   Reply With Quote
Old 07-24-2012, 05:41 PM   #3
johnandret
Not Yet Wild
 
Join Date: Mar 2011
Posts: 53
Default Re: '01 Club Car won't run!

hello, if you put a spark tester between the plug wire and plug you can run it and see if it is ignition or not. if it is disconnect the kill wire at the engine this will seperate it from the switches, if it runs normal then you know its not at the engine and further down the line.
johnandret is offline   Reply With Quote
Old 08-01-2012, 06:13 PM   #4
Kelley97
Not Yet Wild
 
Join Date: Jul 2012
Posts: 4
Default Re: '01 Club Car won't run!

Got my club car running. I am no carb guy but i knew I had a fuel prblem. After cleaning the carb and fuel pump twice, I put it all back together. It would run at half throttle and cut out at full throttle. I adj, the screw on the motor end of the carb and it took off running. I guess whatever was stuck in there turned loose. Running like a champ now.
Kelley97 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 06:50 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.