05 Club Car Help!!!!!

buggy1 · 09-10-2011, 10:23 AM

05 Club Car Precedent Elec. recently purchased. Mods: speed codes 3, light kit. Cart worked fine for the first few days. Then slowly began to just stop working right in the middle of riding it. Would wait a little bit and it would run again. Then cart got to where it wouldn't run at all with only clicking at the pedal. Check the forum and went through all the test and came to the conclusion it was the solenoid. The clicking when pressing the pedal went away. Prior to replacing the solenoid the reverse buzzer would work like it should,though the cart wouldn't move. Now after replacing the solenoid the cart will not move, no clicking, no reverse buzzer. Not sure what to do now. I try and fix one thing and now it's worse.

shadowman · 09-10-2011, 10:51 AM

did you put it in tow when you changed the soleniod? ...........................

buggy1 · 09-10-2011, 11:52 AM

shadowman · 09-10-2011, 12:09 PM

ok put it back in tow than disconnect the neg. cable from last battery let it sit a miute or so and hook back up see if that solves it, also even though its a new soleniod jack the rear up and try jumping it see if cart will run its possible you got a bad one ( wouldn,t be the 1st time) and if for nothing else it can tell us which way to troubleshoot...........................

buggy1 · 09-10-2011, 01:01 PM

Ok, i'll let u know what happens. Just to make sure, the last battery is the front one on the passenger side right?

shadowman · 09-10-2011, 01:21 PM

if you have six 8 volt batteries its the rear one on drivers side.......if you have four 12 volt batteries its the one that has the neg. cable that gos thur the hole in the OBC i,m not sure of location...........................

buggy1 · 09-10-2011, 01:31 PM

Oh, sorry I have 4 12v batteries, and i see which one you r talking about. Trying it now. cross your fingers.

buggy1 · 09-10-2011, 01:42 PM

That didn't work. What's next?

buggy1 · 09-10-2011, 01:51 PM

This could go a little faster if you wouldn't mind calling me. I could give u my cell#?

shadowman · 09-10-2011, 07:30 PM

buggy sorry went out after my last post and just got back......i don,t have time right now i have several hours of paperwork sitting here looking at me and tomorrow morn i have to help a buddy for a few hours but after that i,ll be free for awhile.....................................

09-10-2011, 10:23 AM	#1
buggy1 Not Yet Wild Join Date: Aug 2011 Location: Wadesboro, NC Posts: 47	05 Club Car Help!!!!! 05 Club Car Precedent Elec. recently purchased. Mods: speed codes 3, light kit. Cart worked fine for the first few days. Then slowly began to just stop working right in the middle of riding it. Would wait a little bit and it would run again. Then cart got to where it wouldn't run at all with only clicking at the pedal. Check the forum and went through all the test and came to the conclusion it was the solenoid. The clicking when pressing the pedal went away. Prior to replacing the solenoid the reverse buzzer would work like it should,though the cart wouldn't move. Now after replacing the solenoid the cart will not move, no clicking, no reverse buzzer. Not sure what to do now. I try and fix one thing and now it's worse.

09-10-2011, 10:51 AM	#2
shadowman The Last Moja Morani Join Date: Jan 2007 Location: jumping from cart to cart Posts: 8,975	Re: 05 Club Car Help!!!!! did you put it in tow when you changed the soleniod? ...........................

09-10-2011, 11:52 AM	#3
buggy1 Not Yet Wild Join Date: Aug 2011 Location: Wadesboro, NC Posts: 47	Re: 05 Club Car Help!!!!! Yes.

09-10-2011, 12:09 PM	#4
shadowman The Last Moja Morani Join Date: Jan 2007 Location: jumping from cart to cart Posts: 8,975	Re: 05 Club Car Help!!!!! ok put it back in tow than disconnect the neg. cable from last battery let it sit a miute or so and hook back up see if that solves it, also even though its a new soleniod jack the rear up and try jumping it see if cart will run its possible you got a bad one ( wouldn,t be the 1st time) and if for nothing else it can tell us which way to troubleshoot...........................

09-10-2011, 01:01 PM	#5
buggy1 Not Yet Wild Join Date: Aug 2011 Location: Wadesboro, NC Posts: 47	Re: 05 Club Car Help!!!!! Ok, i'll let u know what happens. Just to make sure, the last battery is the front one on the passenger side right?

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

09-10-2011, 01:21 PM	#6
shadowman The Last Moja Morani Join Date: Jan 2007 Location: jumping from cart to cart Posts: 8,975	Re: 05 Club Car Help!!!!! if you have six 8 volt batteries its the rear one on drivers side.......if you have four 12 volt batteries its the one that has the neg. cable that gos thur the hole in the OBC i,m not sure of location...........................

09-10-2011, 01:31 PM	#7
buggy1 Not Yet Wild Join Date: Aug 2011 Location: Wadesboro, NC Posts: 47	Re: 05 Club Car Help!!!!! Oh, sorry I have 4 12v batteries, and i see which one you r talking about. Trying it now. cross your fingers.

09-10-2011, 01:42 PM	#8
buggy1 Not Yet Wild Join Date: Aug 2011 Location: Wadesboro, NC Posts: 47	Re: 05 Club Car Help!!!!! That didn't work. What's next?

09-10-2011, 01:51 PM	#9
buggy1 Not Yet Wild Join Date: Aug 2011 Location: Wadesboro, NC Posts: 47	Re: 05 Club Car Help!!!!! This could go a little faster if you wouldn't mind calling me. I could give u my cell#?

09-10-2011, 07:30 PM	#10
shadowman The Last Moja Morani Join Date: Jan 2007 Location: jumping from cart to cart Posts: 8,975	Re: 05 Club Car Help!!!!! buggy sorry went out after my last post and just got back......i don,t have time right now i have several hours of paperwork sitting here looking at me and tomorrow morn i have to help a buddy for a few hours but after that i,ll be free for awhile.....................................