95s throttle response instant any adjustments

[firerighter]

just bought a carryall II put a 6" lift and 22' tires and some camo clad. me and my boys are having ablast with it . One of my several problems is when I step on the gas the cart jumps to full speed there is no in between. Is there a sping or a cable that needs to be adjusted thank tom, great site

[scottyb]

Nice looking cart, Tom. There is a little black box under the drivers butt.... remove the lid and adjust a bit of slack into the throttle cable where it attaches to the box ..... see if that gets it ......I'm guessing someone adjusted it too tight trying to get a little more go!

[firerighter]

much better but now the cart will not shut off after the pedel is depressed I did a degrease job this morning could this be part of the problem thanks again

[scottyb]

Are you saying the motor won't shut off once it starts? There are two micro switches on the same throttle device in the black box where you just adjusted the cable one switch operates a ground circuit which cuts out the ignition system to stop the engine ....

[firerighter]

I thought that may be the problem is it ok to put wd on the electrical inside the box, and do you think I put too much slack in the cable thanks

[scottyb]

It is NOT OK to put WD40 on electrical switches .... Good ole WD40 is highly flammable Long story / short = I found an old wood planner in a fallen down shed I cleaned it and cleaned it with wd40 and plugged it in..... When I flipped the switch then entire machine poofed into flames
Be careful with that stuff.... and yes you may have too much slack in the cable for the cam to actuate the switch.....

[Big Bump]

Check your carburator and make sure the butterfly is
still in there.