|
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles |
|
Thread Tools | Display Modes |
08-07-2016, 04:28 PM | #1 |
Not Yet Wild
Join Date: Aug 2016
Posts: 4
|
Starter generator stops working after getting hot.
I have a G9 Yamaha gas golf cart that I have got running outside of the starter generator gets hot and when activating the pedal it will not start or even roll over. When it cools down it will again work. I have replaced the brushes and voltage regulator without any luck. Any suggestions what to look for next I would appreciate.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-08-2016, 12:55 AM | #2 |
G8 Specialist
Join Date: Jun 2009
Location: Phoenix
Posts: 7,799
|
Re: Starter generator stops working after getting hot.
To start with, is the armature binding when you try to spin the starter by hand, with the belt removed?
If it turns freely, go to the sticky up top, "So your yami won't turn over"!! And follow the test sequence !! And Welcome to the site!! |
08-08-2016, 08:23 AM | #3 |
Not Yet Wild
Join Date: Aug 2016
Posts: 4
|
Re: Starter generator stops working after getting hot.
It does roll over and start. After about a half hour it will not start or roll over when it gets warm.
|
08-08-2016, 05:59 PM | #4 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: Starter generator stops working after getting hot.
That would be an odd failure. Ive never seen one do that. I have however seen a solenoid stop working when hot.
|
08-09-2016, 01:58 PM | #5 |
Not Yet Wild
Join Date: Aug 2016
Posts: 4
|
Re: Starter generator stops working after getting hot.
Ok being odd would you say it is the solenoid probably?
|
08-09-2016, 07:23 PM | #6 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: Starter generator stops working after getting hot.
I would say that's when it fails, you check to see which part is not working. Should be very simple with a few bypasses to see if you can get the cart to run, when it stops.
|
08-10-2016, 02:15 AM | #7 |
Not Yet Wild
Join Date: Jun 2016
Location: Nevada
Posts: 19
|
Re: Starter generator stops working after getting hot.
Mine does the exact same thing it's my solenoid if you tap on it it should work again for at least one start
|
08-11-2016, 08:32 AM | #8 |
Not Yet Wild
Join Date: Aug 2016
Posts: 4
|
Re: Starter generator stops working after getting hot.
Ok easy with some bypass tests. Any way this can be explained what to bypass and where? I do not want to short circuit anything causing larger issues.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
09 precedent stops working. | Electric Club Car | |||
88 ezgo gas starter/generator stuck in starter mode | Gas EZGO | |||
05 precedent stops suddenly then starts working again | Electric Club Car | |||
Cart stops working after a while | Electric EZGO | |||
Pedal stops working after a while | Electric EZGO |