|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
09-07-2015, 10:51 PM
|
#1 |
|
Gone Wild
Join Date: Feb 2015
Location: Myrtle Beach S.C
Posts: 151
|
club car stopping after short rides
I have a 04 club car ds 48 volt. It has high speed motor upgraded controller and new HD solenoid ( just replaced ) after driving for about 15-20 min it will come to a stop and reverse buzzer will buzz a few times. I let it sit and it's runs again. Can't figure out the problem. Also has new batteries.
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
09-08-2015, 01:40 AM
|
#2 |
|
Old Sky Soldier
 Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: club car stopping after short rides
What is your battery voltage? Check total and voltage of each battery. One could be going bad.
|
|
|
|
|
09-08-2015, 06:10 AM
|
#3 |
|
Guest
Posts: n/a
|
Re: club car stopping after short rides
Controller Over Temperature.
check for red led flashing when cart shuts down |
|
|
|
09-09-2015, 06:51 AM
|
#4 |
|
Gone Wild
Join Date: Feb 2015
Location: Myrtle Beach S.C
Posts: 151
|
Re: club car stopping after short rides
Probably going to get out and mess with the cart today. Where would I see the led light on the actual controller.
|
|
|
|
|
10-07-2015, 06:24 PM
|
#5 |
|
Gone Wild
Join Date: Feb 2015
Location: Myrtle Beach S.C
Posts: 151
|
Ok so no red light on controller but the motor was really hot. Any suggestions
Sent from my SM-G900T using Tapatalk |
|
|
|
|
10-07-2015, 07:31 PM
|
#6 |
|
Gone Wild
Join Date: Jul 2015
Location: Alpharetta, GA
Posts: 226
|
Re: club car stopping after short rides
What do your cables look like? Are they corroded? Did you upgrade the cables when you upgraded the controller and motor? A high speed motor will generate more heat and if the cables can't carry the load, well you know the rest.
|
|
|
|
|
10-07-2015, 08:36 PM
|
#7 |
|
Gone Wild
Join Date: Feb 2015
Location: Myrtle Beach S.C
Posts: 151
|
Ok so someone had a stud replaced on the motor. I found this wire could this be the problem lol
 Sent from my SM-G900T using Tapatalk |
|
|
|
|
10-07-2015, 08:42 PM
|
#8 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: club car stopping after short rides
Why do You have 2 cables on that motor post? where do they go?
|
|
|
|
|
10-07-2015, 08:45 PM
|
#9 |
|
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: club car stopping after short rides
Looks like you need a good set of golf cart battery cables. Those look like Walmart jumper cables with ring terminals.
|
|
|
|
|
10-07-2015, 08:49 PM
|
#10 |
|
Gone Wild
Join Date: Feb 2015
Location: Myrtle Beach S.C
Posts: 151
|
Both wires go to the controller
Sent from my SM-G900T using Tapatalk |
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Club car precedent wheels stopping | Electric Club Car | |||
| 94 club car belt too short | Gas Club Car | |||
| Club Car ds intermittent stopping/starting | Electric Club Car | |||
| Short somewhere on early Club Car | Electric Club Car | |||
| short in 48 volt club car '95... | Electric Club Car | |||
Linear Mode
