|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-11-2016, 09:27 PM | #1 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Cart applies regen braking when decelerating please help
Hi, I have a 2010 club car precedent pq : I have seen a few posts on this issue but never any results . The problem can occur in forward and reverse, when decelerating the reverse indicator audibles and cart begins motor braking. I can let off pedal and press go again and resumes running again . I have replaced speed sensor and jumped out mcor 2pin same results . I am going to jump out key switch and try it , I have also already jumped out fnr with no changes . Was told there is a diode behind tow switch which I will also check . Just hoping someone can chime in who has been through this before . Thank you
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-12-2016, 04:56 PM | #2 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: Cart applies regen braking when decelerating please help
This sounds like an FR switch issue to me. I would try swapping it out. I believe it's just a 3 position rocker switch under the housing...
|
07-12-2016, 05:21 PM | #3 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: Cart applies regen braking when decelerating please help
If you want to eliminate regen braking install a 4 pole magnet on your motor. They are also referred to as speed magnets.
|
07-12-2016, 05:35 PM | #4 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Re: Cart applies regen braking when decelerating please help
Thanks for info jakesnake already bypassed still same issue
|
07-12-2016, 06:18 PM | #5 | |
Gone Wild
Join Date: Sep 2012
Location: Chestermere, Alberta - Canada
Posts: 1,146
|
Re: Cart applies regen braking when decelerating please help
Quote:
|
|
07-12-2016, 06:41 PM | #6 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Re: Cart applies regen braking when decelerating please help
Sure did josam still didn't change issue but thanks for the input
|
07-13-2016, 02:30 PM | #7 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Cart applies regen braking when decelerating please help
Ken, did you receive my email asking you to monitor solenoid coil voltage?
|
07-14-2016, 12:05 AM | #8 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Re: Cart applies regen braking when decelerating please help
Yes sir I sure did , ran my printer to death also printing out troubleshooting section in club car service manual as well . Plan on taking jack ,stands , my sweet fluke multimeter,a ton of patience, and a 15 pack of bud light to the camper this weekend . With a little luck and all the great advice from you and the techies on this site hopefully I can nail it down . Thanks again to you and everyone else for your advice and sharing of your knowledge,I will follow up on this forum if and when I get her fixed .
|
07-14-2016, 06:03 PM | #9 | |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Cart applies regen braking when decelerating please help
Quote:
|
|
07-16-2016, 04:07 PM | #10 |
Not Yet Wild
Join Date: Nov 2015
Posts: 61
|
Re: Cart applies regen braking when decelerating please help
Hey all , so ran out of beer and patience . All system checks good , solenoid coil is dropping voltage . Went thru electrical again could not locate diode even with print and opening plastic housing . From tow switch to sonic weld to coil no diode unless they install it sonic weld ? . Leaning towards speed controller is there any trouble shooting to completely rules this out ? FYI batteries are 2014 and test shows good .
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Questions about regen braking (or other types of electronic braking) | Electric Yamaha | |||
Regen braking question. My cart has 2004 components?? | Electric Club Car | |||
Regen braking | Electric Club Car | |||
Regen Braking is not Working on PDS cart | Electric EZGO | |||
97 regen cart...I HATE REGEN BRAKING!! | Electric Club Car |