|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
02-18-2014, 08:56 PM | #1 |
Not Yet Wild
Join Date: Jan 2013
Posts: 44
|
Burning up motors?
What causes a motor to burn up? I have burnt up two with in the last 6 months. I think the first one was due to high speeds. No idea on the 2nd one. I have been taking it easy on it. Could weak batteries cause one to burn up?
Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-19-2014, 06:18 AM | #2 | |
Techno-Nerd
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
|
Re: Burning up motors?
Quote:
An electric motor is an energy conversion device. It converts electrical energy into either motion or heat. Ideally, most of the energy is converted into motion and not much into heat, but the way electric motors are used in golf carts is often less than ideal. A stalled motor (0RPM) will convert 100% of the amps flowing through it into heat. The formula is W=IČR. W is Watts of heat I is Amps (quantity is squared) and R is the resistance (or impedance) of the motor. As the magnetic field generated by the Armature (or rotor) of an electric motor spins within the magnetic field generated by the Stator (or Field) windings, and electromotive force is generated whose polarity is the opposite of the voltage being applied to the motor (called Back EMF), effectively increasing the impedance of the motor and reducing current flow through the motor. Without mechanical drag, the motor's RPM will increase until the Back EMF equals the Applied voltage. At that point, 100% of the electrical energy is being converted to motion. In real life there is always mechanical drag, so some of the electrical energy is always being converted to heat. Accelerating from a standstill, climbing hills, turning tall tires (or high speed gears), pulling/carrying heavy loads and driving at low speeds in general, produce more heat than cruising along at mid to maximum speed on a hard, level surface. My motor(s) get hotter driving around my 2 acres of bumpy, but mostly level, land at less than 6-10 MPH than driving at max speed for 10 miles. Running at high RPM may explode a motor (I did) or seize a bad bearing, but it shouldn't overheat the motor unless the motor is undersized for the mechanical load it is attached to. Since you are burning out motors, you might want to monitor your motor temperature. Attached are pictures of how I do it. ------------ Weak batteries (Low voltage) may be a contributing factor, but the way the cart is set up and driving style are more likely the cause. |
|
02-19-2014, 08:24 PM | #3 |
Gone Wild
Join Date: Sep 2012
Location: Savannah, GA
Posts: 2,760
|
Re: Burning up motors?
Excellent explanation Johnnie.
Another way to monitor temp is an inferred temp gun. Cheap at harbor freight. What setup and mods do you have? All stock? |
02-21-2014, 03:25 AM | #4 |
Gone Mad
Join Date: Oct 2009
Location: Buford, GA
Posts: 8,988
|
Re: Burning up motors?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Burning oil? | Gas Club Car | |||
My G9 is burning oil. | Gas Yamaha | |||
Burning oil... | Gas Yamaha | |||
G2 need some speed, burning oil | Gas Yamaha | |||
Wire burning | Electric Club Car |