lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 09-06-2009, 10:55 AM   #1
Paxdad
Gone Wild
 
Paxdad's Avatar
E-Z-GO
 
Join Date: Aug 2008
Location: Cumming, GA
Posts: 313
Default Troubleshooting Help 03 TXT

I have an 03 TXT with the following components
Altrax controller 400 amp
EMP 2 speed motor
4 gauge wires
Trojan T-105 Batteries

All connections are clean and tight batteries are tested to 6.50 volts and all load test as good.

The cart was experiencing heat problems across all battery wires from the F/R switch as well as the pack. Dissambled F/R switch and found a loose stud on board side and replaced along with HD Buss Bars. The cam board shows significnat heat signs but did not replace.

The cart is still experiencing heat problems in all battery wires and on F/R board and on positive wires from solenoid to controller. The only problem I can identify is that the F/R studs are not mated evenly and there are gaps in the surface between the board studs and the cam studs. Could this be the likely cause of the entire system heating up?
Can a stock solenoid cause this problem with the upgraded components above?
Paxdad is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
troubleshooting Electric golf carts
battery troubleshooting Electric EZGO
G22E Troubleshooting Electric Yamaha
95 EZ- GO troubleshooting Electric EZGO


All times are GMT -5. The time now is 06:53 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.