|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
01-12-2016, 03:01 PM | #1 |
Not Yet Wild
Join Date: Aug 2009
Location: florida
Posts: 66
|
96 txt 36V goes forward no reverse
My daughter ran the batteries down to 29v. Charged it up The cart worked fine but a couple days later after she was driving for a while it would go forward but not reverse I immediately thought controller. The Solenoid clicks the orange wire has power going to the controller but no reverse.. I checked all connections a few were a little loose I tightened them. nothing.. I have another txt that I have not run and don't know if it did run because it came without batteries.. I pulled the controller hooked it up and no reverse, it does the exact same thing the solenoid clicks.. Now I know its possible to have 2 bad controllers but I'm hoping it's something else... Any ideas.. As far as i know the switch is good because im getting power to the orange wire to the controller... Anyhting else I can try? Thanks in advance
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-12-2016, 03:05 PM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: 96 txt 36V goes forward no reverse
Series drive cart with rotary F&R switch? If yes it may be the switch.
|
01-12-2016, 03:46 PM | #3 |
Not Yet Wild
Join Date: Aug 2009
Location: florida
Posts: 66
|
Re: 96 txt 36V goes forward no reverse
The orange wire coming from the reverse switch has power when in the Reverse position.. That wire leads to the controller.. So I thought that meant the switch is good ?
|
01-12-2016, 04:39 PM | #4 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,173
|
Re: 96 txt 36V goes forward no reverse
That means the micro switch is good but the rotary switch contacts may be bad.
|
01-12-2016, 07:29 PM | #5 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: 96 txt 36V goes forward no reverse
What drive system are you asking about?
|
01-12-2016, 07:32 PM | #6 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: 96 txt 36V goes forward no reverse
If PDS then yes, you could have a bad control if no reverse when power to pin 2 on plug J1
|
01-12-2016, 09:57 PM | #7 |
Not Yet Wild
Join Date: Aug 2009
Location: florida
Posts: 66
|
Re: 96 txt 36V goes forward no reverse
It's series
|
01-13-2016, 09:01 AM | #8 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,417
|
Re: 96 txt 36V goes forward no reverse
Series, Orange wire only activates 1/2 speed reverse, not the reverse operation.
Try tightening the 9/16 center pivot shaft nut on the cart's rear side of the F&R. Lack of contact here is the likely culprit. |
01-13-2016, 09:05 AM | #9 |
Gone Wild
Join Date: Apr 2013
Location: Deep Run, NC
Posts: 2,544
|
If it's a series it almost has to be the forward and reverse switch or the large wires coming from it.
|
01-13-2016, 09:12 AM | #10 |
Not Yet Wild
Join Date: Aug 2009
Location: florida
Posts: 66
|
Re: 96 txt 36V goes forward no reverse
Ok thanks Scottyb I'll look into it..
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Forward/Reverse, drives forward then jumps in reverse | Electric EZGO | |||
2006 ezgo forward is reverse and reverse is forward please help | Electric EZGO | |||
Reverse alarm sounds in Forward, wont go forward or reverse | Electric Club Car | |||
Alarm sounding in forward. No movement in forward or reverse | Electric Club Car | |||
Forward Reverse switch melted on forward...have question about replacement part | Electric Club Car |