lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV.



Post New Thread  Reply
 
Thread Tools Display Modes
Old 03-17-2016, 09:11 PM   #1
ddh2433
Not Yet Wild
E-Z-GO
 
Join Date: Mar 2011
Location: St.Louis, Mo.
Posts: 27
Default Charger with correct amp rating

I'm looking to buy an on board charger. I just bought new batteries and they r 170 amps @ 20 hr. Is a 13 amp charger sufficient enough or would a 19.5 amp charger be better. On some of the forums I read that for an example for what I have a 17 amp or higher would be better for battery longevity. BTW I have a 6/8volt US batteries.
ddh2433 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 03-18-2016, 07:53 AM   #2
Helirich
Gone Wild
 
Join Date: Sep 2015
Posts: 572
Default Re: Charger with correct amp rating

I think you know the answer to this question. I guess you could go with a 2 amp charger. It just matters how quick you want it to charge. More is better, up to a point. (Batteries don't like to be charged to quick) But 19.5 will be no problem.
Helirich is offline   Reply With Quote
Old 03-18-2016, 07:59 AM   #3
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
Default Re: Charger with correct amp rating

Google is your friend.

The initial or bulk phase of the charge cycle should be close to 10% of the batteries capacity. Since you have opted for low capacity 8v (170ah) the 13 amp charger is okay for these. 19 amps is over kill but will not hurt them as it will back down in the 2nd and 3rd phases of the charge algorithm.
scottyb is offline   Reply With Quote
Old 03-18-2016, 08:21 AM   #4
Helirich
Gone Wild
 
Join Date: Sep 2015
Posts: 572
Default Re: Charger with correct amp rating

Trojan recommends a maximum charger between 10 and 13 percent. But that is of the whole pack. So that would mean you could have a charger of 132 amps. (170x6x13%) But they say a lesser charger will just take longer to charge.
Helirich is offline   Reply With Quote
Old 03-18-2016, 08:42 AM   #5
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
Default Re: Charger with correct amp rating

These is more to it than that. And you are misreading what you found.

They are recommending 10% of the battery amp hour capacity. As previously discussed this week on the forum batteries require more than a trickle of amperage to remain healthy. Google battery equalization and stagnation
scottyb is offline   Reply With Quote
Old 03-18-2016, 09:45 AM   #6
Helirich
Gone Wild
 
Join Date: Sep 2015
Posts: 572
Default Re: Charger with correct amp rating

As per Trojan:
"There are many types of chargers available today. They are usually rated by their start rate, the rate in amperes that the charger will supply at the beginning of the charge cycle. When selecting a charger, the charge rate should be between 10% and 13% of the battery’s 20-hour AH capacity. For example, a battery with a 20-hour capacity rating of 225 AH will use a charger rated between approximately 23 and 30 amps (for multiple battery charging use the AH rating of the entire bank). Chargers with lower ratings can be used but the charging time will be increased."

Read it how you like.

Edit also found this on Trojan:

"Many experts recommend that batteries be equalized periodically, ranging anywhere from once a month to once or twice per year. However, Trojan only recommends equalizing when low or wide ranging specific gravity (+/- .015) are detected after fully charging a battery."
Helirich is offline   Reply With Quote
Old 03-18-2016, 10:03 AM   #7
Sergio
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
Default Re: Charger with correct amp rating

The issue is that "Bank" does not necessarily means "Batteries Connected in Series".

If Your read again the page where You got the information from (near the top):
http://www.trojanbattery.com/tech-su...y-maintenance/
When You connect batteries in "Series", only the "Bank" voltage increases, the total AH of the "Bank" will be equal to the lowest AH battery in the "Bank".

Also the high AH deep cycle batteries cannot be charged with lower current, it is not just a matter of how long it takes.
Sergio is offline   Reply With Quote
Old 03-18-2016, 03:45 PM   #8
270Handiman
Gone Wild
E-Z-GO
 
Join Date: Dec 2013
Location: SE Louisiana
Posts: 257
Default Re: Charger with correct amp rating

It also say this on down toward the bottom under the solar application section

"Many charge controllers have equalization settings that you can set to help ensure the health of your batteries. Equalize your batteries at least once per month for 2 to 4 hours, longer if your batteries have been consistently undercharged."

I know we're not using them for solar, but obviously equalization isn't a bad thing or they wouldn't recommend doing it at least once a month.
270Handiman is offline   Reply With Quote
Old 03-18-2016, 04:43 PM   #9
JohnnieB
Techno-Nerd
 
JohnnieB's Avatar
E-Z-GO
 
Join Date: Jun 2011
Location: West Virginia
Posts: 19,654
Default Re: Charger with correct amp rating

It appears Trojan's proof reader ought to co-ordinate their efforts more closely.

Below are cut&paste excerpts from their Quick Start User's Guide and User's Guide (Complete edition).

The two guides have two differing recommendations.


Trojan recommends equalizing flooded batteries (NEVER AGM or Gel batteries) only when batteries have low specific gravity, below 1.235 or wide ranging specific gravity, > 0.030 points between cells, after fully charging. Please consult Trojan Battery’s complete User’s Guide and your battery charger’s user manual for detailed instructions on equalization.

4.4.3 Equalizing (deep-cycle flooded/wet batteries only)
Equalizing is an overcharge performed after fully charging deep-cycle flooded/wet batteries. An equalizing charge prevents battery stratification and reduces sulfation which are leading causes of battery failure. Trojan recommends equalizing every 30 days or when batteries have a low specific gravity reading after fully charging, below 1.235, or have a wide ranging specific gravity of >0.030 points between cells.

Both are attached in PDF format for your reading enjoyment.
Attached Files
File Type: pdf Trojan_QSG_Flooded.pdf (865.2 KB, 0 views)
File Type: pdf TrojanBattery_UsersGuide(2).pdf (1.64 MB, 0 views)
JohnnieB is offline   Reply With Quote
Old 03-18-2016, 06:17 PM   #10
ddh2433
Not Yet Wild
E-Z-GO
 
Join Date: Mar 2011
Location: St.Louis, Mo.
Posts: 27
Default Re: Charger with correct amp rating

Thanks for all the input everyone. So will I be better off with the 13 or 19.5 amp Lester charger. What I get out of it is the 20 hr. Amp rating is 170 for my battery type so a 17 amp charger is what would be recommended. If I'm wrong can someone explain it simpler.
ddh2433 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric EZGO


Thread Tools
Display Modes


Similar Threads
Thread Forum
RXV QE charger code doesn't seem correct? Electric EZGO
Correct charger Electric Club Car
Correct charger procedure Garage and Workshop
?correct charger OBC, or no OBC Electric Club Car
correct charger amps? Electric golf carts


All times are GMT -5. The time now is 05:54 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.