|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
03-26-2017, 06:00 PM | #1 |
Gone Wild
Join Date: Apr 2015
Posts: 461
|
Ezgo RXV will not run
My RXV had the brake issue after replacing the brake now it will not run just makes several clicking noises.
Help |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-26-2017, 06:38 PM | #2 | |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Ezgo RXV will not run
Quote:
Later model RXVs have similar looking plugs and caps marked #1, #2, #3, and #4. Those are for bypassing the motor brake for an 'emergency' brake unlock feature in case the tow mode switch does not work due to controller test failure. If you have those, make sure they are plugged in correctly for normal operation... Plug #2 into Cap #1, and Plug #3 into Cap #4. Bob |
|
03-26-2017, 06:43 PM | #3 |
Gone Wild
Join Date: Apr 2015
Posts: 461
|
Re: Ezgo RXV will not run
I can hear the motor running but no movement
|
03-26-2017, 06:52 PM | #4 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Ezgo RXV will not run
Jack up the rear of the cart and block it up. Remove both rear wheels and look to see if the axle shaft/nut turns when you hear the motor run. If you can hold a hub from turning while the axle shaft/nut turns, you may need new hubs. They are known to strip out. Sometimes the nuts are just loose and can be tightened. Check first. If they are not turning, you may have an issue inside of the rear end assembly.
Where are you located? |
03-26-2017, 07:33 PM | #5 |
Gone Wild
Join Date: Apr 2015
Posts: 461
|
Re: Ezgo RXV will not run
Okay i jack it up and still not movement
|
03-26-2017, 07:51 PM | #6 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Ezgo RXV will not run
|
03-26-2017, 07:55 PM | #7 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Ezgo RXV will not run
I have RXV axle parts is why I asked where you were.
|
03-26-2017, 08:24 PM | #8 |
Gone Wild
Join Date: Apr 2015
Posts: 461
|
Re: Ezgo RXV will not run
Yes I removed the wheels. Nothing turning. But it sounds like something maybe turning inside or a humming noise. The cart was working prior to changing the brake motor.
|
03-26-2017, 08:40 PM | #9 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Ezgo RXV will not run
Ok, so take the motor brake off of the motor and lay it nearby with the wire attached. Try operating the cart while watching the motor shaft at the motor brake end of the motor. It should turn a tiny bit, maybe 1/4 of a turn then stop. If it does, put the motor brake back on, making sure that you get the motor shaft flats aligned into the flats of the opening in the center of the motor brake. Then rotate the motor brake to align the mounting bolts and put the bolts in. Do not tighten the bolts too much, just enough to flatten out the lock washers. Then try operating the cart again with the back of the cart still off of the ground.
|
03-26-2017, 08:49 PM | #10 |
Gone Wild
Join Date: Apr 2015
Posts: 461
|
Re: Ezgo RXV will not run
Okay I took motor brake off and laid to the side still connected. The motor did spin backwards (I look like) then cart started beeping
|