|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
06-14-2019, 10:24 PM | #1 |
Not Yet Wild
Join Date: Jun 2019
Location: Ohio
Posts: 16
|
2009 rxv no rev no forward no rev beep
I have a 2009 48v RXV that I am at a loss with. The cart will not go forward and will not reverse and now does not make reverse sound either. I have charged all batteries cleaned and tightened all connections , installed a new solenoid and still nothing. Pack voltage test to 50.9 v has not been on in 3 days. I have not yet checked the run plug but will be doing that in the am. Any other help is greatly appreciated.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-15-2019, 11:53 AM | #2 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,221
|
Re: 2009 rxv no rev no forward no rev beep
This could be one of many things. Your not passing the start up tests at all. This would be a good time for a Danaher handheld programmer.
Here is the Danaher troubleshooting guide to help you out if you don't already have it. |
06-15-2019, 03:56 PM | #3 |
Not Yet Wild
Join Date: Jun 2019
Location: Ohio
Posts: 16
|
Re: 2009 rxv no rev no forward no rev beep
Thank you so I had the solenoid wired incorrectly because the new one is a differ t configuration . Now I am getting power to the cart the solenoid does click when put into reverse and the back up alarm does sound still no movement. Forward selection same thing. I put my multi set to dc and get 50.9 v on the large posts. I’m sort of at a loss at this point. Any advice in direction would be very helpful and much appreciated. I have attached two photos not 100% sure if I have the solenoid completely correct.
|
06-15-2019, 04:08 PM | #4 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: 2009 rxv no rev no forward no rev beep
If I recall, the white wire goes on the other large terminal.
|
06-15-2019, 04:26 PM | #5 |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,221
|
Re: 2009 rxv no rev no forward no rev beep
|
06-15-2019, 06:02 PM | #6 |
Not Yet Wild
Join Date: Jun 2019
Location: Ohio
Posts: 16
|
Re: 2009 rxv no rev no forward no rev beep
No originally it had a 36 v solenoid so I purchased a 48v and installed. Ok so whit wire is this going to a capacitor. Other issues since diagnosed potentiometer and switch on as side not working , motor brake not disengageing any and all help would be greatly appreciated
|
06-15-2019, 06:13 PM | #7 | |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,221
|
Re: 2009 rxv no rev no forward no rev beep
Quote:
That white wire is coming from the big white resistor under the heat shield. It goes on the large stud on solenoid that the red cable goes to the B+ on the controller. Get all your wiring right first and work from there. |
|
06-16-2019, 09:38 AM | #8 |
Not Yet Wild
Join Date: Jun 2019
Location: Ohio
Posts: 16
|
Re: 2009 rxv no rev no forward no rev beep
curious why a 48v cart would need a 36v solenoid? and have found that the switch on the gas pedal has no power.
Sent from my iPhone using Tapatalk |
06-16-2019, 10:08 AM | #9 | |
Gone Wild
Join Date: Mar 2014
Location: NE Indiana & SW Florida
Posts: 3,221
|
Re: 2009 rxv no rev no forward no rev beep
Quote:
The controllers post mid-2014 had a main coil (solenoid) PWM value of 100% (48 VDC). |
|
06-16-2019, 12:22 PM | #10 |
Not Yet Wild
Join Date: Jun 2019
Location: Ohio
Posts: 16
|
Re: 2009 rxv no rev no forward no rev beep
so will using a 48 v solenoid cause adverse issues?
Sent from my iPhone using Tapatalk |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2009 rxv wont go and has a steady beep in any key position but off, also no park brak | Electric EZGO | |||
2009 rev stuck in reverse and back up alarm sounds in neutral and forward | Electric EZGO | |||
2009 RXV Forward Reverse Issue | Electric EZGO | |||
Reverse beep-beep-beep delete? | Electric EZGO | |||
02 PDS beep beep beep beep..... | Electric EZGO |