|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-27-2017, 05:20 PM | #1 |
Gone Wild
Join Date: Dec 2010
Location: Orlando
Posts: 382
|
Precedent keeps trying to reboot
A friend just came down to FL after being away and his golf cart was dead. I had a look at it and realized his batteries were dead and upon further inspection noticed some wires were loose. Whoever installed his batteries used the wrong thread nuts and stripped the threads on the posts. I installed new batteries and the low battery light kept coming on and going off. I connected a handheld Curtis computer to see if I could read the fault codes and the computer kept cycling on and off also. I am assuming the controller is bad but I doubt there is a way to test it if it will not stay powered up? All other wires look good and are in the right spots.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-27-2017, 08:12 PM | #2 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Precedent keeps trying to reboot
What's the total battery pack voltage at the moment?
|
01-28-2017, 09:38 AM | #3 |
Gone Wild
Join Date: Dec 2010
Location: Orlando
Posts: 382
|
Re: Precedent keeps trying to reboot
50.2
|
01-29-2017, 10:15 PM | #4 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Precedent keeps trying to reboot
There's either a short in the controller itself or the on-board computer. The OBC supplies power to the controller. Temporarily bypass the OBC to see if the controller will stay on. Un-plug the six pin connector from the OBC and install a jumper wire or paper clip between the blue wire and the white wire on the plug (wire harness side, not OBC side). See how she acts with the jumper in place.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
01 DS, constant OBC reboot required. | Electric Club Car | |||
Club Car Precedent Dual Action Heavy Duty Overload Leaf Spring For CC Precedent | Electric Club Car | |||
Tried to reboot obc | Electric Club Car |