|
10-10-2017, 10:19 PM
|
#1 |
|
Not Yet Wild
Join Date: Aug 2016
Posts: 29
|
2006 Par car 48v questions
Hello ,
I picked up a project cart and when in forward you hear a faint beeping noise as if it was in reverse but not as loud. When I put it in reverse it beeps loudly but will give you whip lash and runs very fast when you push the accelerator. In forward motion it has no where near the speed or power than it does in reverse. All battery voltage range from 6.2 to 6.5 voltd and its a 48 volt system. Any ideas what might cause this erratic behavior? |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
10-11-2017, 08:32 AM
|
#2 |
|
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,383
|
Re: 2006 Par car 48v questions
Being a project cart hard to tell if any wiring has been changed over the last 10 years.
For speed, make sure motor is installed correctly. The F wires flip. Motor A1 to Controller A1 Motor A2 to Controller A2 Field F1 to Controller F2 Field F2 to Controller F1 If the wires on the F's aren't swapped like they should be, it goes the opposite direction. That aside, your battery voltage is fine. The faint beeping can also be caused by moisture Can you load a photo of the face of the controller and the motor wiring? |
|
|
|
|
10-11-2017, 10:02 AM
|
#3 |
|
Not Yet Wild
Join Date: Aug 2016
Posts: 29
|
Re: 2006 Par car 48v questions
thats strange , why do they flip f1 and f2 ? I will check this out and take a pic.
|
|
|
|
|
10-11-2017, 10:17 AM
|
#4 |
|
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,383
|
Re: 2006 Par car 48v questions
They are flipped because that's how the axle is mounted in the vehicles to provide room for the motor to be mounted.
|
|
|
|
|
10-11-2017, 08:32 PM
|
#5 |
|
Not Yet Wild
Join Date: Aug 2016
Posts: 29
|
Re: 2006 Par car 48v questions
Here are the requested pics , need to find a diagram of the controller and cart.
|
|
|
|
|
10-11-2017, 09:15 PM
|
#6 |
|
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,383
|
Re: 2006 Par car 48v questions
That is not a 2006. Its a late 90’s or early 2000’s.
Your issue may be that controller, which is swrviceable with an Alltrax unit. Check the 96-2000 service manual for troubleshooting and the oarts manual for wiring diagrams. Www.buggiesgonewild.com/columbia-parcars |
|
|
|
|
10-11-2017, 09:46 PM
|
#7 |
|
Not Yet Wild
Join Date: Aug 2016
Posts: 29
|
Re: 2006 Par car 48v questions
Thats what the seller told me , go figure it would be something different.
something weird is going on , drove it today a couple of times . took off strong then falls on its face. Now nothing happens when you switch the key in forward or reverse . |
|
|
|
|
10-14-2017, 11:22 PM
|
#8 |
|
Not Yet Wild
Join Date: Aug 2016
Posts: 29
|
Re: 2006 Par car 48v questions
anyway to jump out or test the F R switch?
|
|
|
|
|
10-14-2017, 11:43 PM
|
#9 |
|
How Can I Help?
Join Date: Oct 2009
Location: SW Wisc & West Central, FL
Posts: 1,383
|
Re: 2006 Par car 48v questions
Would need to know which fr switch-it has so really need a vin. Check the frame tube above the rear ledt wheel for a data plate.
|
|
|
|
|
10-16-2017, 07:55 AM
|
#10 |
|
Not Yet Wild
Join Date: Aug 2016
Posts: 29
|
Re: 2006 Par car 48v questions
okay I will look for it, thanks
|
|
|
|
 |
|
||||||
| Thread Tools | |
| Display Modes | |
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| 2006 EZGO TXT PDS- Questions | Electric EZGO | |||
| I'm Baaaack ... Did Ya Miss Me? 2006 MPT Questions | Gas EZGO | |||
| 2006 ezgo gas quick questions | Gas EZGO | |||
| 2006 Precedent clutch and diff questions | Gas Club Car | |||
| 2006 Precedent Tire Replacement Questions | Electric Club Car | |||
Linear Mode
