|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-29-2019, 10:31 AM | #1 |
Not Yet Wild
Join Date: Sep 2019
Posts: 4
|
2005 (I think) TXT with PDS will not run and charger will not activate
Cart will not run and charger will not activate.
Connections all seem solid Charger is OK as it activates on other carts Lights work Reverse buzzer sounds Solenoid clicks when depressing accelerator Curtis controller 73326G07 Have been experiencing intermittent shutdowns Previous occasional odor of heat as well Last edited by Amcgowan; 09-29-2019 at 10:35 AM.. Reason: Additional info |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-29-2019, 11:30 AM | #2 |
Gone Wild
Join Date: Sep 2017
Location: South Texas
Posts: 449
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
If the pack voltage is too low... the charger won’t activate
|
09-29-2019, 11:42 AM | #3 |
Not Yet Wild
Join Date: Sep 2019
Posts: 4
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
Thanks for the reply. Really new at this ... how do I determine the pack voltage?
|
09-29-2019, 12:01 PM | #4 |
Gone Wild
Join Date: Sep 2017
Location: South Texas
Posts: 449
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
Use a multimeter... set it to 200V DC... black lead to negative terminal connected to the controller... red lead to terminal that’s connected to the solenoid... battery 1 & 6... the end batteries
Then test the batteries individually... red to +... black to -... no need to disconnect from other batteries to test individually |
09-29-2019, 12:03 PM | #5 |
Gone Wild
Join Date: Sep 2017
Location: South Texas
Posts: 449
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
Fair warning... I’m new at this too but these guys have taught me a lot over the past couple years
|
09-29-2019, 12:53 PM | #6 |
Gone Wild
Join Date: Sep 2017
Location: South Texas
Posts: 449
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
There’s also a diagnostic mode on that cart... turn the key off... set the run/tow switch to run... flip the fnr switch from N to R and back 5 times and listen to the beeps... there’s a label on the environmental cover of the controller that tells you what error may be indicated by the number of beeps
|
09-29-2019, 01:03 PM | #7 |
Gone Wild
Join Date: Sep 2017
Location: South Texas
Posts: 449
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
|
09-29-2019, 03:13 PM | #8 |
Not Yet Wild
Join Date: Sep 2019
Posts: 4
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
Issue resolved. Turned out I had two batteries that were dead. Replaced both and charger came right on. Cart seems to run fine. Odd thing ... the dead batteries were newest of the 6 by about a year. Go figure.
Thanks for your help!!!! |
09-29-2019, 03:23 PM | #9 |
Gone Wild
Join Date: Sep 2017
Location: South Texas
Posts: 449
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
Don’t be too quick to quit on em... charge em up and test em again
|
09-29-2019, 03:34 PM | #10 |
Not Yet Wild
Join Date: Sep 2019
Posts: 4
|
Re: 2005 (I think) TXT with PDS will not run and charger will not activate
Will do.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
club car charger doesn't activate | Electric Club Car | |||
Gov failure to activate | Gas Club Car | |||
2009 RXV will not activate charger | Electric EZGO | |||
2006 Carryall Will not take charge or activate charger | Electric Club Car | |||
2004 ezgo will not activate charger | Electric EZGO |