|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-29-2019, 01:45 PM | #1 |
Not Yet Wild
Join Date: Mar 2018
Posts: 1
|
96 48v club car has no voltage at solenoid small terminals
So I have an issue with a 96 48v club car. The other day it just stopped moving. I'm pretty sure I narrowed it down to the voltage at the solenoid. I'm not getting any voltage to the small terminals. The ground is good, I jumped the positive post on battery to the other small terminal and the solenoid clicked. The cart jumped when I pressed on pedal. I traced back the wires on that specific terminal, a white/black and a red, but everything looks intact. The white/black runs to a micro switch, with a green/white wire on other end of switch running to the potentimoter. The red wire runs to the controller, small spade terminal labeled 1 in diagrams found on this forum. My question is where does this solenoid terminal get its power from? Does the controller feed along the red wire, or does the black/white feed the power from pontentimoter? No voltage off of either micro switch wire and no voltage at the controller "1" terminal that red wire is ran to.
Sidenote: discovered a burnt wire coming off big post of solenoid running to key switch, green wire, but this wasn't causing the issue. Was still making contact, fixed it and still no voltage at small terminal. Also, the micro switch that the white/black and green/white are wired to seems to be bad. Suppose to be NC but reads open when not engaged. I replaced switch with a confirmed working one but this still isn't fixing the issue. No voltage off of either wire. Any insight would be appreciated. Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-29-2019, 02:43 PM | #2 |
Getting Wild
Join Date: Sep 2014
Posts: 76
|
Re: 96 48v club car has no voltage at solenoid small terminals
place negative probe of mm on last battery negative
place positive probe on solenoid small post positive jack up cart press go pedal r u seeing pack voltage? could be wrong but i dont think those micro switches are nc....... also dont use the word ground when talking golf cart there is no frame ground it is negative |
10-17-2021, 07:33 PM | #3 |
Not Yet Wild
Join Date: Jun 2020
Posts: 11
|
Re: 96 48v club car has no voltage at solenoid small terminals
Did you get this fixed? I'm having a similar problem with mine
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Electrical issue. I get 36 volts to both small terminals on solenoid when gas pedal p | Electric EZGO | |||
36 volts to two small terminals on solenoid zero when gas pedal pushed | Electric EZGO | |||
Voltage drop across solenoid terminals | Electric Yamaha | |||
48 volt CC no power to small terminals on solenoid | Electric Club Car | |||
Terminals too small for solinoid post | Electric EZGO |