lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha
Electric Yamaha Electric Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-13-2017, 01:36 PM   #1
autobus83
Not Yet Wild
 
Join Date: Jul 2017
Posts: 1
Default YDRE Cut-Out

My school just purchased a used 2007 YDRE. Today it just started this weird problem. If I stomp on the pedal it will go for a sec and then cut out. If I slowly step on the pedal then the cart will get going and not cut out. I thought it could be low voltage so I cleaned and resealed all of the terminals. Voltages all look good with a total of 48 volts in the series. When it does cut out sometimes just letting off the pedal will allow you to go again, other times I have to turn the key off and sometimes I even have to flip the tow switch.
autobus83 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 07-13-2017, 02:06 PM   #2
cre73
Getting Wild
 
cre73's Avatar
Yamaha
 
Join Date: Mar 2012
Location: Central Illinois
Posts: 146
Default Re: YDRE Cut-Out

If you only have 48volts the batteries are dead. A fully charged pack will be around 51.5-52.0 volts.
cre73 is offline   Reply With Quote
Old 07-13-2017, 10:33 PM   #3
cgtech
Over This Interview Is...
 
cgtech's Avatar
Yamaha
 
Join Date: Jun 2012
Location: AZ
Posts: 17,449
Default Re: YDRE Cut-Out

You need new batteries. The cut out with tow switch reset is the dead giveaway. If you were to monitor voltages while jamming the gas, you would see it drop way below 40v, it should not be dropping that low, even briefly.
cgtech is offline   Reply With Quote
Old 07-17-2017, 02:33 PM   #4
gooddealtire
Not Yet Wild
 
Join Date: Jul 2017
Posts: 2
Default Re: YDRE Cut-Out

ok what if the batteries not charged in awhile are showing 49-volts and at hard load drop to about 42-volts but occasionally does the shut down to where you have to flip the tow/run switch to get it going again?
gooddealtire is offline   Reply With Quote
Old 07-17-2017, 06:28 PM   #5
cgtech
Over This Interview Is...
 
cgtech's Avatar
Yamaha
 
Join Date: Jun 2012
Location: AZ
Posts: 17,449
Default Re: YDRE Cut-Out

Get the batteries charged first. No point trying to diag anything when the batteries are dead.
cgtech is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
B2 does not fit YDRE Electric Yamaha
Is a G29 and a YDRE the same? Electric Yamaha
YDRE, again Electric Yamaha
YDRE Slow Electric Yamaha
2007 ydre Electric Yamaha


All times are GMT -5. The time now is 07:22 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.