|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-05-2011, 03:04 PM | #11 |
Not Yet Wild
Join Date: Jan 2011
Posts: 8
|
Re: Carryall I shakes violently in forward and reverse
Only in my dreams would they get rid of anything for free! They wouldn't even give me a rusted up beaten to the ground truck that apparently hasn't been touched in years!
Ok so now they want me to run compression checks on the engine..what specs am I looking for? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-05-2011, 03:55 PM | #12 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: Carryall I shakes violently in forward and reverse
Around 160 psi is nominal, (full, wide open throttle while cranking)
Last edited by lockman1; 01-05-2011 at 04:24 PM.. Reason: my numbers were wrong! |
01-05-2011, 04:01 PM | #13 |
just leave me alone
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
|
Re: Carryall I shakes violently in forward and reverse
for - FE 290
read http://www.buggiesgonewild.com/gas-c...pression+fe290 for the 350 (which U probably have) with electric start I was told it had ACR (Automatic Compression Release) and I'm not sure how to measure this ? OOPS lockman can type faster than me. |
01-05-2011, 04:15 PM | #14 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: Carryall I shakes violently in forward and reverse
Yeah Gleemo... I was just reading the manual, and it says 156 psi (min) for an FE290.
I didn't know a 96 Carry-all 1 had an FE350, I thought just Carry-all 2's did... (I've been wrong before, but not often... ) An FE350 (without ACR) is the same as an FE290 An FE350 (with ACR) is 71psi Per the manual(s) anyway... |
01-05-2011, 06:24 PM | #15 |
Not Yet Wild
Join Date: Jan 2011
Posts: 8
|
Re: Carryall I shakes violently in forward and reverse
And the result is about 75psi..it does have the FE290 in it. Does that engine come with an ACR?
|
01-05-2011, 07:07 PM | #16 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: Carryall I shakes violently in forward and reverse
|
01-05-2011, 08:13 PM | #17 |
Gone Wild
Join Date: Oct 2009
Location: Lee County, Georgia
Posts: 521
|
Re: Carryall I shakes violently in forward and reverse
As bad as its been running, I'm hoping its just carbon on the valves.
|
01-05-2011, 10:17 PM | #18 |
Not Yet Wild
Join Date: Jan 2011
Posts: 8
|
Re: Carryall I shakes violently in forward and reverse
That is what I am hoping too but what do you think the chances are that the piston and everything else is ruined since the butterfly is completely gone and I was just told today but one of the guys who drives it that this problem started a while ago and proceeded to get much worse before I finally got ahold of it?
|
01-05-2011, 10:27 PM | #19 |
What the ....?
Join Date: Jan 2007
Location: N.E. Wisconsin
Posts: 14,928
|
Re: Carryall I shakes violently in forward and reverse
Going back in time... to my recollection,
Very few have had any serious problems with their engine after the butterfly was "eaten" Cylinder and Piston damage... not much, (the butterfly will get "chewed up"!) A valve wedged open... a good possibility! But, nobody that I can remember has said anything about any "major" repairs! |
01-06-2011, 08:23 AM | #20 |
Getting Wild
Join Date: Dec 2010
Location: Michigan
Posts: 103
|
Re: Carryall I shakes violently in forward and reverse
I'm no cart expert but wouldn't a wet compression test give a good indication of where the loss is?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
88 Marathon - still scr3wed, need electrical ideas BADLY | Gas EZGO | |||
1992 DS with FE 290 surges badly mid-throttle | Gas Club Car | |||
Taylor Dunn B2-48 Shakes Violently after solenoid clicks and pedal pushed | Electric golf carts | |||
club car electric shakes on start up | Electric Club Car | |||
G16 Rough Ride | Gas Yamaha |