lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha
Gas Yamaha Gas Yamaha Golf Cars; G1 through "The Drive" and U-Max Utility Vehicles



 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 04-06-2011, 12:08 PM   #11
sho305
Vegas modded 420
 
sho305's Avatar
Yamaha
 
Join Date: Jun 2009
Location: West MI
Posts: 15,431
Default Re: G9AG Gearbox snatching

You may have to adjust the cables, usually you can see if it is in neutral with the shifter in the center. If not then its off. They have a little pressure to work against each other, too much and the handle will be hard to move. So you move one up then move the other down the same amount, unless the tension is not correct.

Note you are not supposed to shift while in motion or with engine running. It may clunk once as you start after shifting, but should never grind. The clunk is similar to an outboard that uses a similar dog clutch setup....except those can be shifted while idling. Typically the grinding may be the cables are not putting it all the way into gear, or you have a trans problem.

Zerk is grease gun fitting on edge of engine clutch and on back of secondary clutch usually near the ramps/hub back there. Put about one pump of grease in each, you don't want any getting out and on the belt. Maybe a little more if it has not been done in a year or more. If the clutches do not shift properly you will not get the speed and power the cart can deliver from that massive 10hp in there, lol, if you see what I mean....it can make a big difference.
sho305 is offline   Reply With Quote
 
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Gas Yamaha


Thread Tools
Display Modes


Similar Threads
Thread Forum
Gearbox Identification Big Block Talk!
Snowmobile? Gearbox Identification Gas Club Car
Snowmobile? Gearbox Identification Gas Club Car
wtb- yamaha g16 steering gearbox Golf Carts and Parts
Gearbox Information Required Design Center


All times are GMT -5. The time now is 04:50 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.