|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
07-03-2015, 05:47 PM
|
#11 |
|
Gone Wild
 Join Date: Jun 2014
Location: Green Valley, Az
Posts: 678
|
Re: 99 club car quit running and won't charge
Just had a similar problem with the wife's 97 CC DS series cart with F/R lever by your right leg. I had gone through this cart from A to Z so I was very disappointed when it started acting up. What I found was three micro-switches on the top of the F/R switch and the wires had corroded so badly that one wire broke off with the tab from the micro-switch still attached. You wouldn't think that could happen but it did and it stops the cart from moving...trust me...lol
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
07-03-2015, 06:04 PM
|
#12 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 99 club car quit running and won't charge
The OBC controls both the solenoid negative lead and the charging circuit.
Since You are getting +48v at the solenoid, the circuit through key switch, limit switch and pedal switch is working fine. The OBC is either dead, or it mat just be the fuse on those old carts. Check the red wire coming off the OBC for the fuse and make sure it is good. If so, You can run a jumper (16awg wire) from the small solenoid post where the yellow wire is connected directly to B- or pack negative (whichever is easier). If the cart works fine, the OBC is bad. |
|
|
|
|
07-03-2015, 10:36 PM
|
#13 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
Thanks Sergio I'll try that tomorrow and see what happens, just happened to see your location I'm about a hour from Charlotte I'm close to hickory nc
|
|
|
|
|
07-04-2015, 09:30 AM
|
#14 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
Sergio I just tried that and still nothing. So does that mean the obc is good and something else is bad?
|
|
|
|
|
07-04-2015, 10:13 AM
|
#15 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 99 club car quit running and won't charge
When you said you had positive on both sides of the solenoid, I thought you were talking about the small posts.
What is the serial number of the cart to make sure we are talking about a series drive system? |
|
|
|
|
07-04-2015, 12:19 PM
|
#16 |
|
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: 99 club car quit running and won't charge
From what you say I think you have a bad solenoid. To check place volt meter across small terminals on solenoid. With throttle depressed you should get 48V. Next place meter across large terminals. With throttle depressed it should drop to 0V. Be careful jack up rear end, place on blocks.
|
|
|
|
|
07-04-2015, 10:11 PM
|
#17 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
It is a series cart, way I checked the solenoid was ground one line and checked the big post on solenoid each side was 51v I didn check with throttle pressed. I will check small post tom and do it with pettle pressed and not
|
|
|
|
|
07-05-2015, 09:07 AM
|
#18 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
With throttle pressed I have 0 on big terminals and only 5v on small side. Throttle not pressed 57v on big and 0 on small
|
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Club Car just quit - batteries dead & won't charge | Electric Club Car | |||
| Club Bar just quit - batteries dead & won't charge | Electric Club Car | |||
| 03 Club Car stopped running and it will not charge please help! | Electric Club Car | |||
| 94 club car quit running- again | Electric Club Car | |||
| 2000 48V Club Car quit while running | Electric Club Car | |||
Linear Mode
