|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-17-2011, 02:59 PM | #1 |
Not Yet Wild
Join Date: Jul 2011
Posts: 5
|
surging 2003 cc ds
Hi, I have a 2003 club car DS 48 volt. My problem is when taking off it kinds bucks before it gets going. Also when going up a hill it will slow down to almost a stop then surge forward about 5 or 10 yards and repeat. It was doing fine until I had a party and was told 5 kids were in it going up the hill until it came to a complete stop. It does good on flat ground. Any suggestions?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-17-2011, 03:21 PM | #2 |
Gone Wild
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
|
Re: surging 2003 cc ds
Start with basics of checking voltage of pack with digital volt meter ( 50.96 volts ) and each battery ( 8 volt batterys 8.49 volts, 12 volt batterys 12.73 ). If all batterys test good it could be MCOR ( under passenger floor ) problems, or motor speed sensor on autboard end of motor?
|
07-17-2011, 04:55 PM | #3 |
Not Yet Wild
Join Date: Jul 2011
Posts: 5
|
Re: surging 2003 cc ds
Is there a way to test the MCOR?
|
07-18-2011, 09:54 AM | #4 |
Gone Wild
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
|
Re: surging 2003 cc ds
To test MCOR resistance First remove battery cables in exact way shown in owners manual. Then disconnect the 16 pin connector at the speed controller.
1-"With digital volt ohm meter set at 20K ohms, connect the ( PLUS ) meter probe to the YELLOW wire at 3 wire loom connection, connect the ( MINUS ) meter probe at PURPLE wire. With pedal not pushed the reading should be about 1K, then slowly press pedal should rise to 5.67 ohms and 7.43 ohms". 2-"With digital meter set at 20K ohms, connect the ( PLUS ) meter probe to the YELLOW wire, connect the ( MINUS ) meter probe to the WHITE wire with BLACK stripe. With pedal up the reading should be between 5.67K ohms and 7.43K ohms, with pedal pressed to floor reading should be about 1K ohms. If not testing correctly replace". |
09-16-2011, 09:31 AM | #5 |
Not Yet Wild
Join Date: Sep 2011
Location: Bayville NJ
Posts: 1
|
Re: surging 2003 cc ds
I have the same problem with a 2000 caryall 2 --- just wondering if you ever figured out what was wrong?
|
09-16-2011, 01:25 PM | #6 |
Not Yet Wild
Join Date: Jul 2011
Posts: 5
|
Re: surging 2003 cc ds
I'm not sure but i think it was in the key switch. One time i turned it on and went to back up, it wouldn't go so i cycled the switch a couple times and it hasn't surged since. Got lucky. Might be something to try.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Club Car Surging | Electric Club Car | |||
G22 surging | Gas Yamaha | |||
Surging | Gas Club Car | |||
Surging | Gas EZGO | |||
Surging speed and RPMs on my 2003 CC | Electric Club Car |