08-04-2020, 03:40 PM | #1 |
Not Yet Wild
Join Date: Jun 2020
Posts: 40
|
Cart still stalling...
Hey guys...
Last night I installed a new OEM Kawasaki ignition coil as my cart was stalling after 10 minutes of getting hot. I ruled out the rev limiter as I discovered it wasn't even connected! So once the new ignition coil was installed I reconnected the rev limiter and all was well. Today we took it around the neighborhood, and after 10 minutes or so, it started stalling again. I put it in service mode, pushed down on the pedal and noticed I wasn't hearing the solenoid click. I then put it in reverse and then back again, and it started up. Could it be the solenoid or something else related to coil or rev limiter???? In addition to the coil, over the past couple months I've installed a new starter generator, battery, voltage regulator, carburetor, spark plug, fuel filters and microswitches. Any help you can provide is appreciated as I'm at my wits end with this cart. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-05-2020, 05:55 PM | #2 |
Not Yet Wild
Join Date: Jun 2020
Posts: 40
|
Re: Cart still stalling...
Somebody? Anybody???
I ordered a new solenoid today just in case. |
08-08-2020, 08:30 PM | #3 |
Gone Wild
Join Date: Apr 2012
Location: s e mo
Posts: 169
|
Re: Cart still stalling...
|
08-08-2020, 08:34 PM | #4 |
Not Yet Wild
Join Date: Jun 2020
Posts: 40
|
Re: Cart still stalling...
I would if my kids weren't the primary drivers of the darn thing. I can't trust them not to run it too high.
|
08-09-2020, 07:48 AM | #5 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Cart still stalling...
Can you better describe what you were doing when it stalled?
A bad solenoid would prevent starting, but will not cause it to shut off while driving. A bad rev limiter will cause it to shut off while driving. If that was disconnected before, disconnect it again and see if that problem goes away. If the solenoid failed that would just be coincidental. |
08-09-2020, 06:42 PM | #6 | |
Not Yet Wild
Join Date: Jun 2020
Posts: 40
|
Re: Cart still stalling...
Quote:
https://www.youtube.com/watch?v=_rdBJ3RbBAU https://www.youtube.com/watch?v=x2UV7fEdHYU |
|
08-09-2020, 08:17 PM | #7 |
Bonafide Nincompoop
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 8,987
|
Re: Cart still stalling...
Ok two things. Maybe three.
One disconnect the rev limiter. That can cause strange issues with loss of spark. You're having an intermittent loss of either spark or fuel, and since it starts right back up and drives away you would not be able to test much and find a failure. Two, look for a small hose coming off the top of the carb towards the front of the engine, it should drop down somewhere in front and just kinda hang there. Quite often it's just gone. If the hose is still there, make sure the end of it is not plugged up with dirt or a bug nest. If it's not there, look close at the carb on the front just below the throttle lever, there will be an open port that sticks out about 1/2". Make sure it's not clogged with dirt and/or crud or a bug nest. That port is the vent for the carb bowl, and if it gets clogged or blocked, the bowl will vapor lock and will not allow fuel flow into the carb and it will act almost exactly the way your cart is acting. Third would be to just pull the carb off and clean it out. Possibly the float is getting stuck, or there is debris blocking the fuel inlet into the carb, so it's running out of fuel after you drive it a bit. |
08-11-2020, 04:14 PM | #8 |
Photoshop Guy
Join Date: Aug 2012
Location: Canal Fulton, OH
Posts: 3,846
|
Re: Cart still stalling...
Subscribed.
|
08-12-2020, 07:03 AM | #9 |
Gone Wild
Join Date: Nov 2015
Posts: 460
|
Re: Cart still stalling...
Are you sure it's spark related? I had one do something similar. It would stall out at about the same point every time when riding in my neighborhood.
Ended up being a bit of crud in the fuel pick up line in the tank. I cleaned it out and it solved the issue. |
08-12-2020, 04:42 PM | #10 | |
Not Yet Wild
Join Date: Jun 2020
Posts: 40
|
Re: Cart still stalling...
Quote:
A weird thing I noticed is that The stalling only seems to happen while driving it. While parked in service mode, it will run no problem. i placed a heavy rock on the gas pedal and it ran for over 10 minutes non-stop. Here's a new video, keep in mind it's pretty much shows the same thing. one thing you can't see is that during the video i'm constantly pushing up and down on the pedal until finally it goes. https://www.youtube.com/watch?v=CGnecGqRZMI |
|
|
|
Similar Threads | ||||
Thread | Forum | |||
97 DS keeps stalling | Gas Club Car | |||
G29 stalling?? | Electric Yamaha | |||
Cart is stalling | Gas Club Car | |||
Electric Cart Stalling on Hills? | Lifted Golf Carts |