|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
12-13-2015, 03:20 PM | #1 |
Not Yet Wild
Join Date: Nov 2012
Posts: 17
|
1mph forward and reverse
I have a '89 36v club car. I just changed ALL wires and new batteries. Now it runs about 1 mph in both forward and reverse. I'm pretty sure all connects are correct. Any suggestions?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
12-13-2015, 03:20 PM | #2 |
Not Yet Wild
Join Date: Nov 2012
Posts: 17
|
Re: 1mph forward and reverse
Resistors, could and vglide
|
12-13-2015, 04:01 PM | #3 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: 1mph forward and reverse
Did you make drawings/take pictures before you started? If so post before and what you got now pictures.
|
12-13-2015, 04:48 PM | #4 |
Not Yet Wild
Join Date: Nov 2012
Posts: 17
|
Re: 1mph forward and reverse
I don't have any pictures from before but I wired one cable at a time so I don't think anything got switched.
|
12-13-2015, 05:15 PM | #5 |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: 1mph forward and reverse
I'd start by checking the batteries. They don't look new to me.
|
12-13-2015, 06:28 PM | #6 |
Not Yet Wild
Join Date: Nov 2012
Posts: 17
|
Re: 1mph forward and reverse
I bought the batteries new in sept. I've had them in another cart to break them in and as of this morning they were working great before I took them out.
|
12-13-2015, 07:00 PM | #7 |
Gone Wild
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,027
|
Re: 1mph forward and reverse
What is the second large wire to battery 6?
|
12-13-2015, 07:52 PM | #8 |
Not Yet Wild
Join Date: Nov 2012
Posts: 17
|
Re: 1mph forward and reverse
Motor (2nd lug down from top)
|
12-13-2015, 08:11 PM | #9 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 1mph forward and reverse
Make sure your V-Glide throttle switch is going all the way to the top contact when you put the pedal on the floor. Also, check the battery voltage and let us know what it is. These are very simple systems so the problem shouldn't be hard to narrow down.
|
12-13-2015, 11:21 PM | #10 |
Not Yet Wild
Join Date: Nov 2012
Posts: 17
|
Re: 1mph forward and reverse
Wiper goes all the way to the top. Reading NOT under load was 41. I pulled out the load tester and tested every battery unhooked and all tested good.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Forward/Reverse, drives forward then jumps in reverse | Electric EZGO | |||
EZGO RXV Electric Cart will only go 1mph in forward or reverse | Electric EZGO | |||
2006 ezgo forward is reverse and reverse is forward please help | Electric EZGO | |||
Reverse alarm sounds in Forward, wont go forward or reverse | Electric Club Car | |||
Forward Reverse switch melted on forward...have question about replacement part | Electric Club Car |