|
Gas Club Car Gas DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
07-03-2016, 09:23 PM | #1 |
VC 460 CLONE GONE WILD
Join Date: Oct 2014
Location: Ray BY The Bay NJ
Posts: 10,633
|
Club Car with fe290 Backfiring
My neighbor dropped off his club car with a fe290 in it. When driven hard you can feel the governor back the throttle off and then it starts backfiring.If you run it up in neutral this doesn't happen.I have had yamahas stock and cloned and a harley 2 stroker no club car experience. Any input on where to start looking?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
07-04-2016, 01:04 AM | #2 |
Gone Wild
Join Date: Mar 2016
Posts: 379
|
Re: Club Car with fe290 Backfiring
Has the air filter been changed?
Also check the governor arm and disconnect the rpm limiters(little black box on the front of the engine) ground wire(should be easy to spot it's on the front of the engine) Also try different fuel(could be bad fuel). |
07-04-2016, 10:39 AM | #3 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: Club Car with fe290 Backfiring
Club Car back fire issues are normally in just the throttle cable adjustments. Because so many like to speed the cars up by adjusting the cable in the box, it starts to open the carb too early. Check that first and make sure the engine is cranking over prior to the carburetor opening.
|
07-04-2016, 02:39 PM | #4 |
VC 460 CLONE GONE WILD
Join Date: Oct 2014
Location: Ray BY The Bay NJ
Posts: 10,633
|
Re: Club Car with fe290 Backfiring
The throttle cable was really way to tight, fuel vent was so so and changed out to one of my favorite glass filters.It appears that it would over rev the mechanical governor and the rev limiter would kick in causing the massive backfiring that ensued.Running great again, Stay tuned.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Club car Precedent Backfiring | Gas Club Car | |||
2011 club car precedent gas backfiring | Gas Club Car | |||
Non-Club Car vs. Club Car FE290 Cylinder Heads | Gas Club Car | |||
1991 Club car backfiring and running rough | Gas Club Car | |||
Club Car Backfiring | Gas Club Car |