lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 06-23-2010, 08:57 PM   #1
Double Bogey
Not Yet Wild
 
Join Date: Jun 2010
Posts: 7
Default '95 Club Car Charger Queston

Charger meter will not come up but the charger is humming. Tried my buddies 48v charger and got the same results. Just put on new jumper wires and double checked wires to pos & neg. The cart runs but the batteries aren't taking the charge. I got 7-8v on each battery and 48v from side to side. I can't figure it out.
Thanks
Double Bogey is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 06-23-2010, 09:53 PM   #2
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
Default Re: '95 Club Car Charger Queston

This is a weird charger problem.... OH, it's a club car. Check the pack voltage and check it again at the charger receptacle ... That's a start.

Welcome to BGW!!!
scottyb is online now   Reply With Quote
Old 06-23-2010, 10:19 PM   #3
shadowman
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: '95 Club Car Charger Queston

1995 C.C. chances are you have the red battery light on the dash not the orange one right............99.9 bad OBC....................................
shadowman is offline   Reply With Quote
Old 06-24-2010, 09:24 AM   #4
OLD MEC
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: '95 Club Car Charger Queston

Question did you replace cables before or after problem started? Wiring is so easy to get wrong as we have all done it? Have you checked each batterys for condition? 7-8 volt test means that some batterys "7" volts in pack may be bad. This can cause BOTH chargers not to show amperage on meter as you are trying to charge a bad battery that wont build up enough to show on meter. Its like trying to fill a well with a eye dropper so to speak.
BUT AS SCOTTYB says check voltage at receptical and as SHADOWMAN says you may have bad OBC as both chargers acted the same, or if lucky may only need reset? SEE STICKIES ABOVE for procedure.
SCOTTYB NOW NOW there are other good carts than EZGO?
OLD MEC is offline   Reply With Quote
Old 06-24-2010, 10:18 AM   #5
Double Bogey
Not Yet Wild
 
Join Date: Jun 2010
Posts: 7
Default Re: '95 Club Car Charger Queston

I had the same problem 3 weeks ago and found one of the terminals on a jumper wire was almost corroded off. Replaced the wire and it charged fine. When it happened again I replaced all of them and now no meter movement. Does the small red wire need to be on the same battery as the positive wire to the motor?
Thanks
Double Bogey is offline   Reply With Quote
Old 06-24-2010, 06:02 PM   #6
shadowman
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: '95 Club Car Charger Queston

the 10 gage red wire is mounted to #1 battery pos. post...........same battery that the red 6 gage cable is mounted to solenoid..........rear battery pass. side of cart,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,, ,,,
shadowman is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Club Car 48v Charger Electric Club Car
Club Car 48v Charger Electric Club Car
Club Car Charger Electric Club Car
48v club car charger Golf Carts and Parts
club car charger bad Electric Club Car


All times are GMT -5. The time now is 05:18 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.