05-06-2009, 05:19 PM | #1 |
Not Yet Wild
Join Date: May 2009
Location: Northern Minnesota
Posts: 10
|
96 txt won't charge
I just got a 96 txt. When I purchased it the owner told me it wasn't charging correctly. After reading other posts I tried to diagnose the problem. First I checked voltage at the battery it is 12.87. I then raised the rear end and ran the cart the voltage dropped to 12.2. I then unhooked the green wire on the starter generator and grounded it to the frame and ran the cart again. The voltage still dropped to 12.2. So my question to you all. Is there only one green wire to the starter generator? Did I unhook the wrong one? Also what is bad the generator or the voltage regulator or both? Can the generator be rebuilt?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-06-2009, 05:59 PM | #2 |
Born Wild
Join Date: Mar 2007
Location: Clover SC.
Posts: 5,552
|
Re: 96 txt won't charge
Hope you did ground the starter side of the green wire, if the v/r was bad you would of had a voltage of around 16v. So it should be the start/gen that is the problem. yes those can be rebuilt, I would recommend doing that cause the cost is going to a lot less than a new one.
|
05-06-2009, 08:51 PM | #3 |
Not Yet Wild
Join Date: May 2009
Location: Northern Minnesota
Posts: 10
|
Re: 96 txt won't charge
Thanks for the help. I unhooked the small green wire from the side of starter and grounded it to the frame. What is it that is wrong with the starter generator that causes it not to charge?
What do I need to rebuild the starter? Or is it something I should bring to an automotive electrical repair shop? |
05-06-2009, 09:33 PM | #4 |
Born Wild
Join Date: Mar 2007
Location: Clover SC.
Posts: 5,552
|
Re: 96 txt won't charge
I don't know why your starter/gen is not charging. I would take to a generator shop to be repaired
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
More than just a charge | Extreme DC! | |||
G22 will not charge | Electric Yamaha | |||
When to Charge? | Electric golf carts | |||
98 ezgo charge meter not showing actual charge | Electric EZGO | |||
G16 Will not charge, not even with new s/n! HELP!?!? | Gas Yamaha |