|
Gas EZGO Gas EZGO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-02-2016, 07:56 AM | #21 |
Gone Wild
Join Date: Apr 2009
Location: Vegas NV
Posts: 262
|
Re: 1995 ezgo with 295- runs good but has no power
Tire size? Are you using oversized tires? Inflate tires to at least 18 psi. Check carb float. Ramp shoes, have you replaced them? Maybe you have one missing or almost worn out.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-05-2016, 07:06 PM | #22 |
Not Yet Wild
Join Date: Aug 2016
Posts: 35
|
Re: 1995 ezgo with 295- runs good but has no power
I checked the timing by running cylinders to TDC and looking at the valves. All seemed to be closed. Stock tires. Have replaced buttons and cam on rear clutch and cleaned up front clutch really good. Looks perfectly fine. Any other ideas. Tires are stock. This thing is kicking my ***.
|
09-05-2016, 07:54 PM | #23 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,443
|
Re: 1995 ezgo with 295- runs good but has no power
Some basic things, the cvt is really important and looks like you got most all of that. It may not seem like it but when they shift wrong you get no power to the ground. Also check motor mounts because if the engine moves to the trans under torque it makes the cvt shift wrong. Worn belt also not good, worn sheaves will also make it shift poorly, you can see those by looking where the belt runs the sheaves will be worn in there (dished in). After all that you start looking at engine issues, does the carb open all the way, is the exhaust plugged (more so on some carts than others), does the engine have problems like low compression, timing issue, valve issue, etc., is the governor still on, if so is that screwed up people bend up the linkages and stuff things in them.
|
09-06-2016, 06:18 PM | #24 |
Not Yet Wild
Join Date: Aug 2016
Posts: 35
|
Re: 1995 ezgo with 295- runs good but has no power
I have really been leaning towards a plugged exhaust. Is that a common issue with these?
|
09-14-2016, 07:09 PM | #25 |
Not Yet Wild
Join Date: Aug 2016
Posts: 35
|
Re: 1995 ezgo with 295- runs good but has no power
Well it's not the muffler.... I took that off and checked it out.
|
09-14-2016, 08:21 PM | #26 |
Gone Wild
Join Date: Apr 2014
Location: Ohio
Posts: 960
|
Re: 1995 ezgo with 295- runs good but has no power
did you measure the width of the belt? should be 1 3/16" wide, sorry some how I missed the post where you said you replaced the belt..
|
09-15-2016, 05:28 PM | #27 |
Not Yet Wild
Join Date: Aug 2016
Posts: 35
|
Re: 1995 ezgo with 295- runs good but has no power
Yes. Tried a few different belts.
|
09-15-2016, 05:59 PM | #28 |
Gone Wild
Join Date: Apr 2014
Location: Ohio
Posts: 960
|
Re: 1995 ezgo with 295- runs good but has no power
did you try a new set of plugs, maybe one of them isn't up to par.., I got a video of my ezgo running in neutral and you can see the clutches working good. I could post if you want to see it.
|
09-17-2016, 06:34 AM | #29 |
Not Yet Wild
Join Date: Nov 2015
Posts: 7
|
Re: 1995 ezgo with 295- runs good but has no power
Have you checked the voltage at the coils when the throttle
Is pushed |
09-17-2016, 07:45 AM | #30 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,827
|
Re: 1995 ezgo with 295- runs good but has no power
I'm watching this with interest because I'm working on an 06 with the 4 stroke 2 cylinder Robin with similar issues. This one has some low end power when first started cold, but gets really weak as it warms up. Good compression (150#, 155#), cvt working - stays "down on drive clutch "up" on driven while the engine struggles to gain rpm. Cleaned then changed carb, tried different plugs, even plugged in a different coil- all no change. Adjusted valves and replaced the drive belt too. I'm running out of ideas.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G9 runs rough and backfires, good compression but no power | Gas Yamaha | |||
runs good but no power g1 | Gas Yamaha | |||
Harley Runs Good, Low power? | Gas Harley Davidson | |||
1995 EZGO Medalist has good power after charge then dies | Electric EZGO | |||
1995 EZGO - Good to Start With? | Gas EZGO |