lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars

Post New Thread  Reply
Thread Tools Display Modes
Old 07-01-2014, 01:58 PM   #1
Not Yet Wild
Join Date: Jan 2008
Posts: 6
Default shuttering cart

have elec club car ds 48 volt. Cart shutters on take off in both directions. Checked battery pack and it shows 51 plus volts with no load. Each battery reads 8.3 to 8.5 volts with no load. Under load they will drop into mid 6 volt range. Is this enough power to operate properly? I read a thread that indicated that a weak battery pack might cause the shuttering. Is there another issue that might cause this problem?
possum is offline   Reply With Quote
Alt Today

Golf car forum Sponsored Links

This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
Old 07-01-2014, 03:34 PM   #2
Not Yet Wild
Club Car
Join Date: Jan 2013
Location: Deland, Florida
Posts: 24
Default Re: shuttering cart

At least one bad battery dropping out under load.
allenb12 is offline   Reply With Quote
Old 07-01-2014, 05:46 PM   #3
go to
scottyb's Avatar
Join Date: Dec 2007
Location: Southern California
Posts: 69,582
Default Re: shuttering cart

All batteries dropping 2v or more under load are dropping a cell = dead.
scottyb is offline   Reply With Quote
Old 07-01-2014, 06:44 PM   #4
random bolts
Not Yet Wild
Join Date: Jul 2012
Posts: 71
Default Re: shuttering cart

Hook a multimeter to the pos and neg of the battery pack and go for a ride and see what the voltage drop is. if you see a big drop and don't have a load tester or hydrometer you can run the cart for a minute then jump off and check all the batteries voltage to see if one is way down. that will show you which battery is crapping out if it's a battery issue. if you have a mcor and not a vglide on your cart. it's probably the mcor going out if the batteries are good. i've replaced a lot of mcors because they and jerky like this at low speeds.
random bolts is offline   Reply With Quote
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car

Thread Tools
Display Modes

Similar Threads
Thread Forum
Cart Shuttering Electric Club Car
Help with shuttering G22 Electric Yamaha
Shuttering clutch Gas Club Car
shuttering??? Electric EZGO

All times are GMT -5. The time now is 05:01 AM.

Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2020, vBulletin Solutions, Inc.
This Website and forum is the property of No material may be taken or duplicated in part or full without prior written consent of the owners of 2006-2017 All rights reserved.