|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-13-2009, 03:00 PM | #1 |
Not Yet Wild
Join Date: Jun 2009
Location: Texas
Posts: 23
|
charging issues 48 voltcc
ive done as much homewok as possible this week before asking stupid questions.. club car 1996 royal ride..48 volt system..brand new batteries..charger works on neighbors 48 volt club car but not mine..everything else operates fine. all batteries test at 8.3 volts, and system tests above 49 volts. how can i be sure that obc is problem before i buy new one? can i override obc with jumper wire??? if so which wires?? i am so close to figuring out im about to pull a hammer out. a big hammer! if i get to that point i promise ill take a picture!
thanx for any help! gmave. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-14-2009, 08:38 AM | #2 |
just leave me alone
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
|
Re: charging issues 48 voltcc
Have you tried resetting OBC Yet ?
OBC reset 1.Remove the positive and negative cables from the pack 2. Place the F/R switch in reverse 3. Slowly press the pedal down and hold it for a minute or so. Reverse buzzer should sound until all the power has dissipated from the OBC 4. Re-attach Battery Pack, try charging again !! |
06-14-2009, 08:44 AM | #3 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: charging issues 48 voltcc
Quote:
|
|
06-14-2009, 08:55 AM | #4 |
just leave me alone
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
|
Re: charging issues 48 voltcc
Morning Scottyb ;
is there more than one way to reset OBC , is it year/model dependent ? On another subject how is the 03 IQ project going ? |
06-14-2009, 09:00 AM | #5 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: charging issues 48 voltcc
I threw those disconnects in there because that is the way I got it from the Alltrax web site ......
The IQ cart? Come on over later we are having a bonfire |
06-14-2009, 09:19 AM | #6 |
just leave me alone
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
|
Re: charging issues 48 voltcc
Ok so if there is no run/tow sw then its just the Skip that , Understood !
Im know nothing about IQ carts , but this sound like it has to be part of the IQ programming features ? But if I remember you already tried another Controller ? Thanks dude and good luck on the Bear |
06-14-2009, 09:34 AM | #7 | |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,419
|
Re: charging issues 48 voltcc
Quote:
http://www.buggiesgonewild.com/elect...nightmare.html |
|
06-14-2009, 09:51 AM | #8 |
Not Yet Wild
Join Date: Jun 2009
Location: Texas
Posts: 23
|
Re: charging issues 48 voltcc
i disconnected all wires (radio etc.) to try and reset obc. Ill try disconnecting pos. and neg. from each end of the bank....
|
06-14-2009, 09:57 AM | #9 |
Not Yet Wild
Join Date: Jun 2009
Location: Texas
Posts: 23
|
Re: charging issues 48 voltcc
thanks for the pdf. scottyb..im going through now...
|
06-14-2009, 11:54 AM | #10 |
Not Yet Wild
Join Date: Jun 2009
Location: Texas
Posts: 23
|
Re: charging issues 48 voltcc
resetting didnt work! i did a little more research on the charger and figured out how to jump over the relay. probly not smart but its working for now. the amp meter is still moving so ill monitor and try and decide when its charged. only problem is i dont have very good judgment....jumping the relay was a lucky guess which terminals !!!! thanks for the input!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
99 DS charging issues | Electric Club Car | |||
fe290 issues please help | Gas Club Car | |||
For those having issues | Announcements | |||
EZGO Battery Charging Issues | Electric EZGO |